2025 HYUNDAI TUCSON Safety Overview

Component: FORWARD COLLISION AVOIDANCE

"This is not the first situation NOR the first time it is being "fixed". I took my car in early March for an oil change and informed the representative about the same thing. The time that made me say something is when I was switching lanes and the car must have sensed me being close causing me to stop completely and the car behind me having to hard break and swerve. Rick Case Hyundai in Duluth, Georgia had my car for a MONTH, just for me to experience the same thing over 3 times since then. I received my car in April, and the recall for this wasn't put out until May. I am constantly scared for my life and the passengers I may have lives, as well as the other drivers lives, considering I got this car due to being in a rear end collision. When I took it in April, they CONSTANTLY, drove my car to diagnose it but kept telling me they didn't see the problem, and it wasn't coming up for them on their internal tracking system for their cars(webDCS). Once they finally talked to the CORPORATE field technician, they advised they replace the whole front bumper, including sensors, for the solution. But like stated before, since then I have experienced near crash stops AT LEAST 3 times since then, two of them being in the same month (July 16 and July 28). If this is the same solution, I don't see it being beneficial and I would like to be bought out at this point. Especially if I have to be without my car for a long period of time again."

Component: UNKNOWN OR OTHER

"Infotainment cluster going black. Hyundai refuses to provide vehicle & won’t diagnose issue even after making appt."

Component: ELECTRICAL SYSTEM

"I bought my car in for recalls and they performed service. I got down the road when the HUD started going out over bumps. They could not duplicate it when I bought it back after picking it up. This was yesterday 7/16/26. They have had this car for a total of 18 days not including other issues that I have bought it in for. Today I am having issues with the instrument cluster and HUD going out randomly over bumps still. This is exactly what I explained when dropping it for the repair. This is resulting in me not being able to read the instrument cluster since it displays no signal on cluster or goes completely black."

Component: ELECTRICAL SYSTEM

"The rear door locks and trunk lid do not always unlock. This creates a safety concern for rear passengers because they cannot easily exit the car because door won't unlock. The dealership says issue is intermittent yet it's still happening."

Component: SERVICE BRAKES

"I was intending to make a left hand turn out of a dinner parking lot. As I approached the exit, I saw that a car was about to drive past me preventing me from making that turn, so I put my foot on the brake pedal to stop my car and let the vehicle safely pass in front of me. But the brake did not work. It did not stop my car. The pedal felt limp not firm I turned sharply to the left to avoid striking the other vehicle. Fortunately no other cars were coming in either direction. I put the car in neutral and then in park. Only by the grace of God a collision was averted. I then restarted the car, the brake pedal was now firm again and I drove home. I returned home and left the car in my driveway until Monday, July 13 when I had a tow truck take the vehicle to the dealer. This is not the first time my brakes became soft and limp and failed to stop my car. There have been at least two or three previous incidents over the the past months while backing out of a parking space, the brake pedal became limp. In those instances I was able to stop the vehicle by putting it in park. When I restarted the vehicle, the brake returned to being firm. These incidents are intermittent. I don't know when and where they will occur. To date, the dealer claims not to have found anything wrong with my brakes. Apparently, unless they can replicate my experience directly themselves, they intend to send me on my merry way. I don't consider the vehicle is safe to drive. The intermittent problems I have had with the brakes all occurred in exiting parking lots and not on the highway at 55 MPH - fortunately. These incidents occurred. The brakes have failed"

Component: SERVICE BRAKES,FORWARD COLLISION AVOIDANCE

"The automatic emergency braking system activated early and aggressively causing a rear end collision. It is available for inspection upon request. While driving in busy traffic on a highway I was lightly braking to avoid sudden stops or unexpected movements of the vehicle while traveling between 20-30 mph. The vehicle then activated the emergency braking system and came to a sudden and unexpected complete stop. This sudden stoppage caused myself and my passenger to be thrown forward harshly against the seatbelts. Additionally I was unable to steer the vehicle towards the side of the road as the wheel had locked and avoid an SUV that was rapidly approaching my rear. This SUV subsequently rear ended me. The actual collision was minor thankfully due to the low speed of the traffic, but could have been much more severe if traffic conditions had been different. Has the problem been reproduced or confirmed by a dealer or independent service center? Not yet. (I am in the process of this right now, but because my car was in a collision the dealer will not fix the recall or inspect the vehicle until the collision damage is fixed) Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? See previous answer Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? The vehicle had not exhibited any issues prior to this sudden stopping."

Component: POWER TRAIN,ELECTRICAL SYSTEM,EXTERIOR LIGHTING

"Good morning the problems I am having with my 2025 are very discouraging. Started October of 2025, my tire light illuminated stated the tires were low when they are all at correct specs when using an air guage to check. November of 2025 while driving at night the headlights suddenly shut off briefly then came back back on. January of 2026 while leaving work the transmission would not shift, held accelerator pedal to floor but could not go above 20 mph all the way home for 3 miles. April of 2026 the right side of navigation screen went completely black, shut vehicle off twice and on third restart the screen reilluminated. June of 2026 same thing with the screen going black. I have had my Tuscon at the local dealer here in my town for supposedly a repair that they state was a "coaxel cable" behind the dash that was fixed that was causing this issue. I also had the recall performed for the front view camera software update but it is still showing not completed. This is very frustrating to be having experiencing these kind of issues on this new of a vehicle. Clearly something is going on with the software or something and the dealer keeps telling me they are not finding anything wrong. I am a service advisor myself at a small independent shop so I understand the terms they are using but something needs to be addressed to correct the issues that I am having. It is scary when driving and the screen goes black or driving at night and losing the headlight functions. I would appreciate if somebody will look into this and reach out to me to get some kind of remedy for why this is happening. I am paying alot for this vehicle and to say I am satisifed is an understatement. I have purchased Hyundai as my choice of vehicle due to the quality, great warranties and good reviews from other consumers however I am seriously thinking of exploring alternative makes as I do not want to keep going through this. Plus the engine consumes oil. I have attached p/w for review as well"

Component: POWER TRAIN,ELECTRICAL SYSTEM,EXTERIOR LIGHTING

"Good morning the problems I am having with my 2025 are very discouraging. Started October of 2025, my tire light illuminated stated the tires were low when they are all at correct specs when using an air guage to check. November of 2025 while driving at night the headlights suddenly shut off briefly then came back back on. January of 2026 while leaving work the transmission would not shift, held accelerator pedal to floor but could not go above 20 mph all the way home for 3 miles. April of 2026 the right side of navigation screen went completely black, shut vehicle off twice and on third restart the screen reilluminated. June of 2026 same thing with the screen going black. I have had my Tuscon at the local dealer here in my town for supposedly a repair that they state was a "coaxel cable" behind the dash that was fixed that was causing this issue. I also had the recall performed for the front view camera software update but it is still showing not completed. This is very frustrating to be having experiencing these kind of issues on this new of a vehicle. Clearly something is going on with the software or something and the dealer keeps telling me they are not finding anything wrong. I am a service advisor myself at a small independent shop so I understand the terms they are using but something needs to be addressed to correct the issues that I am having. It is scary when driving and the screen goes black or driving at night and losing the headlight functions. I would appreciate if somebody will look into this and reach out to me to get some kind of remedy for why this is happening. I am paying alot for this vehicle and to say I am satisifed is an understatement. I have purchased Hyundai as my choice of vehicle due to the quality, great warranties and good reviews from other consumers however I am seriously thinking of exploring alternative makes as I do not want to keep going through this. Plus the engine consumes oil. I have attached p/w for review as well"

Component: FORWARD COLLISION AVOIDANCE

"I lease a 2025 Hyundai Tucson SEL. This vehicle has experienced repeated electrical and safety system malfunctions. Display/infotainment failure: The center display has shut off while driving on at least 10-15 separate occasions. This has occurred while I was actively using CarPlay for navigation in an unfamiliar area, causing loss of directions while driving. Forward collision/automatic emergency braking (AEB) malfunction: The AEB system engaged unexpectedly and unpredictably while I was driving on the highway, causing the vehicle to brake suddenly. This resulted in another vehicle rear-ending me. This occurred while I was driving home from a doctor's appointment. I understand this vehicle/system was subject to a manufacturer recall related to this issue. AEB failure to engage when needed: On a separate occasion, while I was backing out of a parking spot, the emergency braking system did not engage or respond when needed, and I narrowly avoided being struck (T-boned) by another vehicle. Warning system malfunction after repair: Following the highway incident, I brought the vehicle to an authorized Hyundai dealer, who performed a front safety system software update. Approximately two days later, while driving on the highway, a dashboard warning appeared related to the front safety system. This warning disabled cruise control and other related features. Dealer inspection/dispute: I brought the vehicle back"

Component: FORWARD COLLISION AVOIDANCE

"I have had nothing but trouble with software issues since the very first recall (software related) on my vehicle, just a few months after I purchased it. I have had a very difficult time having Hyundai address these issues, and recently opened my third case with Hyundai. The issue: On 6/24/26 Peddar Hyundai conducted the software update for the recall regarding the front collision system. Later in the day on 6/24/26 and in the days following, whenever I turned on the car, Googlemaps would automatically pop up on the infotainment screen, the car’s navigation voice (not the googleMaps voice) would instruct me to turn right or left, etc. throughout the drive, despite no route being set. I have a video of this occurring. MOST CONCERNING: 6/25/26 I was pulling out of a parking lot, with no other cars or obstacles in my path, going slowly, and the automatic braking system ground the car to a stop. There was no warning on the dash. It took a few seconds before the car would allow me to accelerate. This is the very problem the software update was supposed to fix. 7/2/26 I was using GoogleMaps navigation at night and as I was driving, the infotainment system went blank and I had no navigation. After a minute or so the map came back on, but it was just spinning in circles and couldn’t right itself. Additional issues: the infotainment system randomly keeps popping up the question, asking if I want to open Google Maps. Sometimes when using the parking camera, an informational window keeps popping up stating “Press the button to display the camera view, or press and hold to activate the parking assist system”. I use this function every day, but for some reason, at times it keeps trying to teach me how to use it. (These types of glitches have happened before after software updates.) 6/26/26 I opened a case with Hyundai. Case number 42790134. I have yet to hear from them. I've called several times and they won't return my call or address this safety issue."

Component: SERVICE BRAKES, HYDRAULIC,FORWARD COLLISION AVOIDANCE

"The contact owns a 2025 Hyundai Tucson. While the contact’s son was driving approximately 55 MPH on a three-lane highway, the brakes locked up. While attempting to move the vehicle to the shoulder, the driver lost control of the vehicle and struck the guardrail and rolled over several times. The air bags deployed, and the glass shattered. There were no injuries reported. A Police report was filed. The contact associated the failure with NHTSA Campaign Number: 26V316000 (Forward Collision Avoidance). The vehicle was towed from the scene to a tow lot. The local dealer was not contacted, and the vehicle was not diagnosed or repaired. The insurance company later towed the vehicle to the facility and deemed the vehicle a total loss. The manufacturer was notified of the issue; however, an assigned case manager had not responded. The approximate failure mileage was 19,081."

Component: ELECTRICAL SYSTEM

"I purchased a 2025 Hyundai Tucson in March of 2026. Shortly after the purchase the screen began to malfunction. The screen glitches continuously while driving and there is no way to turn it off. This creates a significant distraction and raises serious concerns about driver safety. Especially driving at night. The screen turns completely dark then all of a sudden comes back in super bright. Because of the glitching there is no way to get to the setting to possibly turn the brightness down. It also creates a loud noise for about 10 minutes then resets itself and start all over again. I notice there was a recall about the screens glitching previously and I reached out to Hyundai and they informed my VIN wasn’t apart of the recall so there was nothing that could be done. Because the vehicle is over 60K miles I am not able to use the factory warranty. I believe it is unreasonable for a vehicle that is only a 2025 model to experience a major electronic failure after such a short period of ownership. Regardless of warranty limitations, consumers should be able to expect that critical vehicle systems, particularly those affecting safe operation, will function properly. I respectfully request that Hyundai and/or the selling dealership review this matter and provide goodwill assistance by covering the diagnostic fee and repairing or replacing the defective infotainment screen. I believe this would be a fair resolution considering the age of the vehicle, the timing of the failure, and the potential safety implications. I have taken a few screenshots of the video I recorded to show what is happening. I am not able to upload the video so you can hear the loud noise it makes."

Component: BACK OVER PREVENTION,FORWARD COLLISION AVOIDANCE

"I had the Hyundai recall 302 performed on 5/27/2026 and after the software update none of the front sensors worked. My wife had a 2 mph bump with the car in front of her on [XXX]and there was no warnings, also no damage no injuries that I'm aware of. So I started to investigate why there was no alarm sounded or any red warning light on the dashboard. Pulled the car into the garage and up to 6 inches from the garage wall no warning on the dash. Took the car back to the dealership on 6/5/2026 they changed some settings and it still failed to warn of an still failed. The gave me a service appointment on 6/9/2026 they calibrated the front windshield sensor and now the parking assist sensors worked. When I pulled into the garage the front camera showed yellow and red warnings as I approached the wall. That fixed the parking sensors issue. Still no forward collision avoidance warning shortly there after was referred to the service manager Rich Block he stated that the front bumper cover would need top be removed to calibrate the radar behind the bumper, but Hyundai's warranty would not cover it and, I should call Hyundai Customer care. I did and was contacted by Mohamed at National Consumer Affairs (714) 922 - 3276. and here we we sit. when they pulled the bumper they found the mounting bracket was bent. Mohamed at National Consumer Affairs (714) 922 - 3276 stated could I prove that all this happened after recall 302. I can only prove the parking sensor issue because after recalibration they worked. Hyundai Motors refuses to accept any responsibility for this incident. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)"

Component: BACK OVER PREVENTION,FORWARD COLLISION AVOIDANCE

"I had the Hyundai recall 302 performed on 5/27/2026 and after the software update none of the front sensors worked. My wife had a 2 mph bump with the car in front of her on [XXX]and there was no warnings, also no damage no injuries that I'm aware of. So I started to investigate why there was no alarm sounded or any red warning light on the dashboard. Pulled the car into the garage and up to 6 inches from the garage wall no warning on the dash. Took the car back to the dealership on 6/5/2026 they changed some settings and it still failed to warn of an still failed. The gave me a service appointment on 6/9/2026 they calibrated the front windshield sensor and now the parking assist sensors worked. When I pulled into the garage the front camera showed yellow and red warnings as I approached the wall. That fixed the parking sensors issue. Still no forward collision avoidance warning shortly there after was referred to the service manager Rich Block he stated that the front bumper cover would need top be removed to calibrate the radar behind the bumper, but Hyundai's warranty would not cover it and, I should call Hyundai Customer care. I did and was contacted by Mohamed at National Consumer Affairs (714) 922 - 3276. and here we we sit. when they pulled the bumper they found the mounting bracket was bent. Mohamed at National Consumer Affairs (714) 922 - 3276 stated could I prove that all this happened after recall 302. I can only prove the parking sensor issue because after recalibration they worked. Hyundai Motors refuses to accept any responsibility for this incident. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)"

Component: SERVICE BRAKES,FORWARD COLLISION AVOIDANCE

"I was driving along a 40 mile an hour road and there was a fork in the road and a car in the opposite lane waiting to turn onto that fork to the right and the car just slammed on the brakes and I was injured very badly. My neck back and hips are hurt very bad."

Component: FORWARD COLLISION AVOIDANCE

"The contact owns a 2025 Hyundai Tucson. The contact stated that while driving at an undisclosed speed, another vehicle slowed down in front of the vehicle, and the Forward Collision Avoidance system activated, the brakes engaged, and caused another vehicle behind to crash into the rear of the contact’s vehicle. No warning lights were illuminated. A Police report was not filed. No injuries were sustained. Medical attention was not needed. The air bags did not deploy. The vehicle was taken to an independent mechanic, where it was diagnosed, and it was determined that the rear bumper, rear hatch, and several other unknown parts under the bumper needed to be replaced. The vehicle was repaired. The contact was notified that the VIN was included in NHTSA Campaign Number: 26V316000 (FORWARD COLLISION AVOIDANCE). The manufacturer was not notified of the failure. The failure mileage was approximately 18,120."

Component: UNKNOWN OR OTHER

"Sunroof exploded I was driving at high speed on a highway. sounded like a gun fired. glass must have flown back towards other cars. Noise was terrifying and I slowed to gain my composure before pulling to the side of the highway and calling the police. Car is currently at a local dealership. My initial thought was that something like a rock hit the sunroof, but on my own inspection it appears the explosion was outward. there is no evidence of something falling on it. no scratches on the inside roof cover which was closed at the time. No makes on the roof rack or scratches on the car roof. There was no warning of any kind from the vehicle that it might occur. after doing some research I discovered that there have been many cases of exploding sunroofs on Hyundai cars. Dealership is under the assumption that a rock hit the roof, but are not willing to give me a report of an examination into what might have caused it. They disregarded my conclusion that it exploded outward."

Component: FORWARD COLLISION AVOIDANCE

"The contact owns a 2025 Hyundai Tucson. The contact stated that while driving at an undisclosed speed, another vehicle slowed down in front of the vehicle, and the Forward Collision Avoidance system activated, the brakes engaged, and caused another vehicle behind to crash into the rear of the contact’s vehicle. No warning lights were illuminated. A Police report was not filed. No injuries were sustained. Medical attention was not needed. The air bags did not deploy. The vehicle was taken to an independent mechanic, where it was diagnosed, and it was determined that the rear bumper, rear hatch, and several other unknown parts under the bumper needed to be replaced. The vehicle was repaired. The contact was notified that the VIN was included in NHTSA Campaign Number: 26V316000 (FORWARD COLLISION AVOIDANCE). The manufacturer was not notified of the failure. The failure mileage was approximately 18,120."

Component: FORWARD COLLISION AVOIDANCE,LANE DEPARTURE

"MULTIPLE WARNING LIGHTS ON THE DASHBOARD, INCLUDING SRS , TCS, ABS , ALL LIGHTS STAY ON EVEN AFTER TURNING THE VEHICLE OFF. SYSTEMS DON'T WORK, SUCH AS LANE DEPARTURE, COLLISION AVOIDANCE & ABS DON'T WORK. SPOKE W/ KOEPPEL HYUNDAI, MENTIONED THE ISSUE, BUT WAS TOLD THAT THAT ISN'T PART OF THE RECALL, THEREFORE THEY WILL NOT ADRESS THE ISSUE. IT'S FRUSTRATING , DON'T FEEL SAFE DRIVING THE VEHICLE. WILL TAKE LEGAL ACTION IF ANY ACCIDENTS WILL HAPPEN DUE TO AN ISSUE THAT THE DEALER IS REFUSING THE ADRESS."

Component: EXTERIOR LIGHTING

"main instrument cluster and Heads-Up Display (HUD) randomly flickering, turning completely black with a "No Signal" message, or triggering all dashboard warning lights."

Component: POWER TRAIN,ELECTRICAL SYSTEM

"The contact owns a 2025 Hyundai Tucson. The contact stated that while in reverse, several warning lights illuminated on the instrument panel, and the vehicle suddenly reversed without depressing the accelerator pedal and crashed into a light post. The air bags did not deploy. There were no injuries sustained. The contact sought medical attention after being overwhelmed by the experience. A Police report was not filed. The contact was able to drive the vehicle, and the vehicle was taken to the dealer, and the front-view camera was updated; however, the dealer was unable to determine the cause of the failure. The vehicle was taken to Imperial Body Shop to repair the body damage. After the software update was performed, the contact became aware that the vehicle failed to turn off immediately, and several attempts were needed to turn off the vehicle. On another occasion, the contact was able to turn off the vehicle; however, the engine continued to run. Several attempts were needed to turn off the vehicle. The manufacturer was made aware of the failure. The manufacturer opened a case for the failure. The failure mileage was approximately 7,500."

Component: POWER TRAIN,ELECTRICAL SYSTEM

"The contact owns a 2025 Hyundai Tucson. The contact stated that while in reverse, several warning lights illuminated on the instrument panel, and the vehicle suddenly reversed without depressing the accelerator pedal and crashed into a light post. The air bags did not deploy. There were no injuries sustained. The contact sought medical attention after being overwhelmed by the experience. A Police report was not filed. The contact was able to drive the vehicle, and the vehicle was taken to the dealer, and the front-view camera was updated; however, the dealer was unable to determine the cause of the failure. The vehicle was taken to Imperial Body Shop to repair the body damage. After the software update was performed, the contact became aware that the vehicle failed to turn off immediately, and several attempts were needed to turn off the vehicle. On another occasion, the contact was able to turn off the vehicle; however, the engine continued to run. Several attempts were needed to turn off the vehicle. The manufacturer was made aware of the failure. The manufacturer opened a case for the failure. The failure mileage was approximately 7,500."

Component: VEHICLE SPEED CONTROL,SERVICE BRAKES,FORWARD COLLISION AVOIDANCE

"On XXX, my vehicle unexpectedly activated its automatic braking system while driving, resulting in a rear-end collision. My infant daughter was in the vehicle at the time. While we were fortunate to avoid catastrophic injuries, the incident placed both of us in significant danger and could easily have resulted in a much more serious outcome. The other driver may also have sustained injuries as a result of the collision. The vehicle sustained approximately $20,000 in damage. Since the accident, I have learned of Hyundai’s recall involving this braking system. Given the circumstances, I am deeply concerned that the condition addressed by the recall contributed to the collision. What is particularly troubling is that this was not the first time I raised concerns regarding the vehicle’s braking behavior. On February 23, 2026, at approximately 11:00 a.m., I spoke with my dealership, North Bay Hyundai in [XXX] regarding unexpected braking behavior that I was experiencing with the vehicle. My concerns were not escalated, and I was not advised that a potential safety issue might exist. Several months later, I was involved in a collision involving the same system that is now subject to recall. I am also deeply concerned by the manner in which this recall was communicated. I received only a text message regarding a defect involving a critical vehicle safety system. Given the potential consequences of unexpected braking events, I do not believe the seriousness of this issue was adequately conveyed to affected customers. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)"

Component: EXTERIOR LIGHTING

"​Before I owned this car, I used to get so frustrated whenever I was driving behind this type of vehicle because the rear blinkers are mounted so incredibly low in the bottom bumper that you can't see what the driver is doing. Now that I actually own a Hyundai Tucson, I feel completely responsible for the drivers behind me. Because I know how low my blinkers and reverse lights are, I have to turn them on way before I actually turn, and I'm always worried someone will hit me when I'm in reverse. On top of that, my friends who drive behind me constantly tell me how bad it is and how hard it is to see my signals because of how low they sit."

Component: FORWARD COLLISION AVOIDANCE

"The forward collision automatic braking happens randomly and for no reason causing immediate and complete stops in the middle of traffic. It whips the head forward as if a crash had occurred and causes drivers to the rear to have to suddenly brake to avoid collision. Ive had it occur multiple times since purchase with the most recent being this morning in the middle of a roundabout. I know I can disable the system but 1) that's also a safety risk and 2) it turns back on every time I start the car which is unacceptable. Ive asked the dealership about it and was told that it cannot be disabled. I already have the sensitivity turned down as much as possible and it still is happening. This issue makes an otherwise wonderful vehicle almost uunrivaled. When this happens there's no warning before the sudden braking. It also will randomly just slow speed down for no reason and with no way for the driver to stop it. Something needs to be done. Fix the system and make available a way to disable it without it auto turning back on. Im fed up."

Component: LANE DEPARTURE,FORWARD COLLISION AVOIDANCE

"Forward collision assist is dangerous. It engages when not necessary and has almost caused several wrecks by slamming on the brakes. There needs to be a way to permanently disable and not have to pick through a series of menus every time. Also, lately I feel like I’m fighting the lane keep assist when I’m on the highway, and it tries to move when not necessary."

Component: UNKNOWN OR OTHER

"While driving the vehicle information system (speedometer, tach, fuel, etc.) goes dark for several minutes. It comes back then it goes out again."

Component: SERVICE BRAKES,FORWARD COLLISION AVOIDANCE

"3 incidents of same braking component. Once while exiting a parking lot, the car slams breaks so hard while accelerating that car slams to hard stop with no warning. Once while driving through an intersection brakes engaged for no reason. Once after stopping at Red light, then when moving with traffic, car stops so hard with no warning that we were almost rear ended and seat belt left marks and bottom of car seemed to hit the ground. These violent automatic breaking events are scary because for no reason or cause and no warning the car suddenly hard brakes. Fear of being rear ended or car flipping from such sudden and hard breaking. This incident has not been inspected although the car is current on all maintenance and has been recently in to car dealer for oil change."

Component: FORWARD COLLISION AVOIDANCE

"My car abruptly stopped due to the emergency braking system when the car in front of me braked (hard) but I had more than enough time to stop without having the emergency braking system engaged. Due to this, the car behind me hit me from behind damaging my bumper, trunk, and back lights"

Component: ELECTRICAL SYSTEM,FORWARD COLLISION AVOIDANCE

"On 5/14/2026, while driving southbound on I-95 with my pregnant wife and young daughter, my 2025 Hyundai Tucson (approx. 7,500 miles, purchased new 10/2025) experienced multiple critical safety failures. Two days prior, the heads-up display (HUD) intermittently failed to activate. On 5/14, traveling at 65-70 mph near [XXX] , the brakes auto-applied without driver input. Simultaneously, the instrument cluster and HUD went completely black, eliminating all speed and vehicle status information. This recurred intermittently. Near [XXX] , the brakes auto-applied with full force, locking all four tires and bringing the vehicle from approx. 70 mph to a complete stop on the active interstate. Two trailing vehicles spun out and left the travel lane to avoid rear-ending us. A multi-car pileup was narrowly avoided. The vehicle was taken to Pearson Hyundai in Midlothian, VA. They diagnosed and replaced a faulty wiring harness. Immediately after the repair, driving northbound on I-95 back to [XXX] (5/16), the lane keep assist/lane departure system began pulling the steering wheel into the adjacent lane without driver input, repeatedly and unpredictably at highway speed. The dealer repair did not resolve the all defects. Within a three days this vehicle exhibited: (1) total instrument cluster/HUD failure, (2) uncommanded emergency braking at 70 mph causing two other vehicles to take evasive action (3) uncommanded steering input into an adjacent lane. These failures created immediate risk of serious injury or death. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)"

Component: FORWARD COLLISION AVOIDANCE

"There have been two instances now within about 4 months where my 2025 Hyundai Tucson's emergency braking/anti forward collision system has engaged completely unnecessarily, slamming on my brakes and almost causing the car behind me to hit me. In both cases there wasn't a car in front of me within at least 100 feet. In both cases I was going probably 30-40 miles per hour."

Component: FORWARD COLLISION AVOIDANCE

"The forward emergency braking system on this vehicle is a hazard not a safety feature. I have almost been rear ended 3 times because of it and have had my neck and back hurt from the quick sudden stop! I was not even at risk of getting into an accident! This feature needs to be permanently disabled! I still owe 30 payments on this car but will be getting rid of it if i can't disable this permanently."

Component: STRUCTURE

"We have had two starburst cracks from very small rocks hitting our windshield on the highway and chips from tiny hail. I have never had a car with such a fragile windshield before. We are constantly worried that it would break easily while driving if something larger hits it."

Component: FORWARD COLLISION AVOIDANCE

"The FCA engages in situations that are not dangerous. There is a slamming of the breaks which causes items in the car to fly off the seat and nearly cause the cars behind me to rear end the car. This is a dangerous situation and has happened about 6 times since we purchased the car less than six months ago. There is not a way to permanently disable this supposed safety feature."

Component: SERVICE BRAKES,FORWARD COLLISION AVOIDANCE

"What component or system failed or malfunctioned, and is it available for inspection upon request? Automatic braking system brakes for no reason when I am not near any cars traveling at high speed or even when I am already at a complete stop or moving very slowly but not anywhere near hitting the car in front of me. This has happened multiple times since I leased this car in July 2025 and it seems to be getting worse. I had a 45 min drive home today and it happened about 7 times all for no reason. How was your safety or the safety of others put at risk? It slams on the brakes unnecessarily and the cars behind me almost rear end me. This has happened on residential roads and highways. Has the problem been reproduced or confirmed by a dealer or independent service center? I just called to take it in. They seemed to have no idea what I was talking about. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? not yet but I am taking it in asap Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? NONE"

Component: POWER TRAIN,SERVICE BRAKES,FORWARD COLLISION AVOIDANCE

"My vehicle has an ongoing safety‑critical defect involving the braking system, powertrain, and ADAS logic. I have not driven the vehicle since 04/27/2026; all diagnostic trouble codes were recorded while the vehicle was in the dealership’s possession. On 05/05/2026, the vehicle stored multiple DTCs, including C164286, P071300, P076800, U060FF1, U060F29, and U061386. On 05/13/2026, P071300, P076800, U060FF1, U060F29, and U061386 were recorded again, showing repeated powertrain, communication, and control‑system faults while the vehicle remained with the dealer. On 05/22/2026, two additional safety‑related DTCs (P107600 and C272146) were first recorded, and both were last reported again on 05/27/2026, still while the vehicle was in dealer custody. These DTCs now show as Historical because the vehicle has not been operated since the last fault was recorded. Their Historical status only means the system has not run a new check — it does not mean the defect is repaired. The vehicle has also exhibited brake‑logic abnormalities, including a persistent Brake‑ON signal at highway speeds, which violates Brake‑Throttle Override safety logic and affects ADAS functions. The powertrain shows signs of torque converter instability, mechanical drag, abnormal slip, and heat buildup documented across these dates. Two OTA updates were performed during periods of instability, but neither corrected the defect. The dealership has not provided documentation confirming the safety issues were resolved. Because the braking logic, powertrain behavior, and repeated DTC activity remain unexplained and unresolved, I do not believe the vehicle is safe to operate."

Component: ELECTRICAL SYSTEM,ENGINE,FORWARD COLLISION AVOIDANCE

"The cars speedometer screen and radio screen go black and sometimes flicker on and off. This makes it impossible to see the speed. Also the car stalls sometimes when this happens in traffic. The autonomous braking applies the brakes even when there is a large distance from other cars and objects to the point where it has almost caused me to get into an accident on numerous occasions. The driver attention alert comes on and off over and over again even though I’m fully focused on driving and well aware of what is going on and this sometimes happens in a sequence where all of the warning lights illuminate on dash. Sometimes all of the warning lights display on cluster after it goes black and then car says to shift to park when display goes back on causing safety concerns for me in traffic. In addition my sunroof glass is making a loud noise like it’s going to crack."

Component: STRUCTURE

"The underbody shield is held up partially by plastic nuts that get loose casing the shield to rattle at speed over 60mpg. I read multiple reports from other owners on reddit. Tightening these plastic nuts help ressolve the rattle temporarly, but the nuts are flimsy and keep spinning. You can't really tighten them well. A good remedy from Hyundai would be to replace these flimsy plastic nuts with metal ones that stay tightened and secure the underbody shield in place. Dealer wasn't helpful and wanted to charge $200 just to look at it"

Component: AIR BAGS,SEAT BELTS

"The contact leased a 2025 Hyundai Tucson. The contact stated that while driving at 40 MPH, another driver cut her off while in an intersection which activated the emergency brake system. As a result, the contact was hit from behind by another vehicle. The air bags did not deploy and the seat belt failed to secure the contact and thrusted her forward. The contact did not seek medical attention but days after the accident, the right side of her neck, right lower shoulder blade, right inner thigh, right side of her chest, left side sciatica, lower right abdomen, and lower back. The authorities arrived at the scene and a police report was filed. Despite the failure and the damage to the vehicle, the contact managed to drive the vehicle home. The manufacturer had yet to be notified of the failure. The vehicle had yet to be diagnosed or repaired. The failure mileage was approximately 15,900."

Component: ELECTRICAL SYSTEM,UNKNOWN OR OTHER

"The head-up display and the digital display cluster turn off and on while driving. The digital display cluster seems to lose connection and will show a "NO SIGNAL" message. This will happen for minutes at a time. When this happens, the display is black and does not show speed or other important safety information. The vehicle has been inspected twice by the dealership; they are not able to replicate the issue. This problem began within weeks of purchasing the new vehicle."

Component: SERVICE BRAKES,FORWARD COLLISION AVOIDANCE

"On at least three occasions, the forward collision system incorrectly determined there was an imminent collision when a car or truck was simply coming over into my lane. The Tucscon locked the brakes, bringing the car to a full stop in the middle of high-traffic roads even while the car in front was pulling away. I was unable to give the car gas to continue driving forward. On two occasions this was on an interstate, going from almost 70 mph to stop when there was no car or obstacle in front of the car. It created a very dangerous risk of being rear-ended. The car did display the message "Collision Warning" on the instrument panel, emit an audible alarm, and shook the steering wheel."

Component: SERVICE BRAKES,FORWARD COLLISION AVOIDANCE

"I was on the freeway about 2 minutes and the car flashed a red warning then slammed on the brakes and I flew forward. No cruise control and no buttons hit or anything automatic. Another time,  I was merging to freeway on ramp (with 2 lanes merging and going to freeway). I was on the left right lane towards the on ramp and another car came speeding next to me on other the on ramp right lane. All of a sudden, my Tucson says emergency braking for about 1 to 3 seconds. slamps the brakes. I am not sure if the other speeding car made a sensor think I was going to merge into him,or him into me, or the sensors didn't detect the lane markings. It's my daily route to this ramp and it has not occurred in the past. These emergency braking incident has happened several times (4-5 times in a month) to me, usually during a highway drive similar to those above. I have to turn off the forward collsion to stop this happening and it comes back on everytime when the car starts from a off."

Component: FORWARD COLLISION AVOIDANCE

"This incident occured in The Woodlands, Texas, about a 45 min drive north of my home. I was headed south on [XXX] . I had pulled into a left turn lane at the intersection of [XXX] . After the oncoming traffic had cleared, I proceeded to make a left turn onto [XXX] . My Hyundai Tucson slammed on the brakes just as I entered the oncoming lane. The FCA was OFF. I was able to hit the gas and start moving forward again before any oncoming traffic got to this intersetion. There was no warning before the brakes were applied. Note, the FCA safety function was absolutely positively turned off. We have gotten into the habit of turning it off to avoid these unintended, unexpected sudden complete stops. Now I'm concerned the FCA system has more problems than just being overly senstive or malfunctioning causing numerous sudden braking issues. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)"

Component: FORWARD COLLISION AVOIDANCE

"I was turning right from [XXX] onto [XXX] . It was raining lightly, the car initiated emergency braking and no one was in front of me. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)"

Component: FORWARD COLLISION AVOIDANCE

"Subject: 2025 Hyundai Tucson - Persistent Phantom Braking Issue I am reporting a severe safety defect regarding the Forward Collision-Avoidance Assist (FCA) system on my 2025 Hyundai Tucson. Since purchasing the vehicle, I have experienced five separate "Phantom Braking" incidents where the Automatic Emergency Braking (AEB) engaged abruptly without any obstacles in the path. In the most recent incident, the vehicle suddenly braked from 30 mph to 20 mph] while driving on a highway. There were no cars or objects in front of me. This unpredictable behavior is extremely dangerous as it almost caused a rear-end collision with trailing vehicles. I believe this is a systemic software or sensor defect that misinterprets shadows or road signs as hazards. I request a formal investigation into this safety risk."

Component: FORWARD COLLISION AVOIDANCE

"The contact owns a 2025 Hyundai Tucson. The contact stated while driving at an undisclosed speed, the brakes independently activated. The contact stated that the vehicle decelerated to 60 MPH and the brake pedal was abnormally firm. The contact stated that the animals in the rear of the vehicle were thrown into the front seat of the vehicle. The contact stated that the seat warmer independently turned on, the touch screen activated and deactivated, and the oil change warning light illuminated. The contact received notification of NHTSA Campaign Number: 26V316000 (Forward Collision Avoidance). The vehicle was taken to the dealer; however, the failure was not duplicated. The contact was informed that the VIN was not associated with the recall. The manufacturer was not made aware of the failure. The failure mileage was approximately 7,000."

Component: SERVICE BRAKES,FORWARD COLLISION AVOIDANCE

"I was driving on the highway in heavy traffic going about 65 mph. An unusual symbol appeared on the dash in red that I don't know what It was or what it meant but I thought it must be something serious. Then a warning came up saying for me to take a break. Then a different warning came up saying that I should take control of the car immediately, it was about to brake. The car immediately began to brake. Fortunately I was in the right hand lane of the three-lane highway and I was able to pull into the breakdown lane. I can't even imagine what would have happened if I was in the middle or far left lane. I was not unobservant and both of my hands were on the steering wheel when this happened. Once the vehicle stopped, the symbol on the dash disappeared and the brakes released. I was able to resume driving. Although there was no accident, injury or fire, and no police report needed, this does not discount the seriousness of this event. This could have been life-threatening if I had been in a different lane or had panicked, causing a multi car pileup in the heavy traffic. Serious enough that I feel the need to get rid of this car."

Component: UNKNOWN OR OTHER

"Vehicle is 2025 Hyundai Tuscon purchased 12/31/2025. On April 18th, as I was backing into my garage i noticed that I could not see through the right side end window. On closer look I noticed that the glass was shattered without any spots of particle hit or point of impact. I stopped and took pictures, took the vehicle to Potamkin Hyundai and the service guy also took pictures. I went back on April 21 to see the service manager who also took pictures and advised me to give them some time to review. After about 1 week, I got the message that the request for replacement under Manufacturer Warranty had been declined and that I would have to replace this on my own."

Component: FORWARD COLLISION AVOIDANCE

"The Automatic Emergency Braking and Forward Collision Warning systems activated while making a left turn after stopping for a red traffic light and locked the brakes of the vehicle in the middle of the intersection with no other car in front of me. Dash alerted that a collision was going to occur. This was the second time. The first time it happened the dealer said it can happen if there is a bug or dirt on the sensor in the bumper or dirty windshield by the camera, they even said it can happen with glare from the sun or light glare."

Component: FORWARD COLLISION AVOIDANCE

"I was stopped behind another car in a through-lane in the parking lot at Marshall's. I was fully stopped about 1 car length behind another stopped car. I decided to make a left turn (from my stopped position) into a perpendicular through-lane in the same parking lot. Just after I drove my entire car to the left of the parked car, my Hyundai Tucson slammed on the breaks. There were no cars coming toward me in the oncoming through-lane. There were no cars in front of me or coming toward me in the perpendicular through-lane. The FCA was OFF. Again, I don't understand why the car is appying the brakes while I'm going forward if the FCA is off."