2020 GMC SIERRA 3500 Safety Overview

Component: POWER TRAIN

"The contact owns a 2020 GMC Sierra 3500. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently went into LIMP Mode. There was no warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed that the transmission valve body sensor had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The approximate failure mileage was 130,000."

Component: VISIBILITY,STRUCTURE

"The contact owns a 2020 GMC Sierra 3500. The contact stated that while driving 45 MPH with passengers seated in the rear seats, the passengers became aware that water was entering the vehicle between the window and frame. There were no warning lights illuminated. The vehicle was taken to the local dealer, who informed the contact of Technical Service Bulletin: 18-NA-383. The vehicle was not diagnosed or repaired. The manufacturer was contacted and confirmed that there was no special coverage or warranty coverage on the vehicle. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 50,000."

Component: UNKNOWN OR OTHER,SERVICE BRAKES,ENGINE

"Engine started skipping, then service parking brake light came on, then service engine light came on and speed dropped to 44 mph."

Component: EXTERIOR LIGHTING,FUEL/PROPULSION SYSTEM,LANE DEPARTURE

"My IntelliBeam function stops working sometimes, I can still use the lights as normal but the IntelliBeam function stops every so often and starts working after about 2 to 10 mins. Lane departure warning stops every so often and will start working after 1 to 10 mins, I have noticed that when it stops working at night time then the IntelliBeam function stops working also. When I press the on/off button for lane departure then it will say that lane departure is unavailable right now. I have been getting a p20ee code showing something is wrong with SCR nox sensor 2. Scan tool reveals that the sensor works normal and then stops. Once I clear the code then it works good for a few days."

Component: POWER TRAIN

"The contact owns a 2020 GMC Sierra 3500. The contact received notification of NHTSA Campaign Number: 24V797000 (Power Train); however, the part to do the recall repair was not yet available. The contact was concerned about the remedy repair not being adequate to repair the vehicle. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect."

Component: FUEL/PROPULSION SYSTEM

"Def heater connection on the tank will arc and melt down causing engine derate and costly repairs. Gm know and has released a service bulletins in 2022. Bulletins N212342980. But even with bulletins done still fails. And talking todealer ships it a very common problem and there is a shortage in parts."

Component: POWER TRAIN

"Valve body failed while pulling my camper down the interstate. Transmission began to have issues and locked up on us while driving. Luckily i was able to avoid any accidents. Had truck towed to a private Transmission shop to have the transmission repaired. Shop advised the failure was due to the faulty valve body."

Component: UNKNOWN OR OTHER

"The tailgate automatically opened while I was driving. I was sure the tailgate was shut and latched properly prior to the incident."

Component: POWER TRAIN

"Greetings. In December 2024, I brought my vehicle in for the rear end lock up recall. The recall reprogrammed the transmission control module. As admitted, by yourself and GM this doesn't fix the problem. In addition, if the lockup occurs and a new valve body is required, GM is on back order with no date for delivery. Also, it is replacing it with the same valve body, i.e. you will have the same problem in the future. Nextgen Drivetrain has a valve body for around $1000 that fixes the problem. [XXX] . Please read the attached blog from Nextgen, they explain in detail, the problems and the fixes. I am scared to death to pull my travel trailer out of state with this looming problem. Please give us a better solution. Thank you. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)"

Component: FUEL/PROPULSION SYSTEM

"I was towing my 44'camper entering the highway and during excellration there was a loud bang and the truck shuddered no lights on the dash. Pulled over and did a visual check of the vehicle and did not see anything out of ordinary. Continued on our journey and during the the week noticed clunking noise when shifting into park and into drive with no camper. We shortened our trip and returned home with no futher incidents. Received recall letter from GM in December, called the dealer and was told Gm has not released my VIN number yet. Called twice in January 2025 and the software was done on February 20, 2025. Truck seems to run as it should. I use the truck for business and to tow my camper. The software is only a patch. My fear is I'm out traveling with my 44' camper and the truck goes into limp mode limiting to fifth gear. Then I have to get the truck towed home and the camper. I travel with 3 dogs too. GM has known about this issue and has failed to fix the problem leaving me and my family at risk of a serious accident. I can not work without my truck and GM does not care about me or my family. I have several camping trips scheduled for this year and I'm considering canceling them because I don't feel comfortable with the software update."

Component: FUEL SYSTEM, DIESEL,ENGINE

"The contact owns a 2020 GMC Sierra 3500. The contact stated while driving approximately 60 MPH, the vehicle jerked, lost motive power, and almost stopped unintendedly. There was no warning light illuminated. The contact was able to pull into a parking lot, where the vehicle shut off. The contact stated that while attempting to restart the vehicle, the diagnostic trouble code: P129F was displayed, and the vehicle failed to restart. The vehicle was towed to the residence. The local dealer was contacted and advised the contact that the failure might be related to the fuel pump control module and that the part was on backorder. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 19,000."

Component: POWER TRAIN

"I have a complaint about the recall response from both nasal and gm. I feel the cure is substandard. Why not just put new transmission control modules in to correct this problem. Very disappointed"

Component: POWER TRAIN

"Contacted General Motors to have the Recall software patch installed, appoint was set, vehicle was dropped off and now they are telling me there is nothing they can do, that the recall is not available. The software update is available, and is being installed on other vehicles. This is a life safety issue as the rear wheels can lock up at any time which could cause a vehicle accident involving the vehicle under recall as well any vehicles on the road around this vehicle when it happens. General Motors should be taking care of this asap instead of waiting. I do not feel safe driving the vehicle until they feel like they installing it."

Component: POWER TRAIN

"The contact owns a 2020 GMC Sierra 3500. The contact stated that while driving at 60 MPH, the rear differential seized, in addition, the contact was hauling a median size tracker on top of a flat bed. The flat bed jackknifed and hit the left side of the contact's vehicle. The vehicle was able to come to a stop. The air bags did not deploy. There was no warning light illuminated. A police report was filed. There were no injuries sustained. The vehicle was towed to a towing yard. The trailer was towed to the residence. The tractor was damaged in the accident. The vehicle was diagnosed by an independent mechanic. The contact was informed that the transmission had failed. The vehicle was not repaired. The insurance company was contacted. A claim was filed with the insurance company, and it was canceled a few days later by the insurance company. The manufacturer was not notified of the failure. The failure mileage was approximately 108,000."

Component: POWER TRAIN

"driving 65mph on interstate, attempted to change lanes to pass slower vehicle and pressed upon accelerator pedal...truck violently skidded to a stop and sent me onto shoulder, many vehicles behind me swerved to avoid my vehicle. GM wont repair and says since they cant replicate its not really happening. this has happened twice in last 2 weeks."

Component: POWER TRAIN

"driving 65mph when vehicle attempted to downshift itself for no reason when instead the rear axles locked up and made a massively loud bang as if axle fell off, let off gas, smoke pouring from rear tires, skidded about 8 feet, it released then locked up 2 more times within 30 secs before I could get off road out of traffic flow. mfd has a tsb for this issue(#21-NA-275 GM) not sure if its transmission or braking system Dealer service could not replicate and told me it was probably my trailer(wasnt traveling with trailer) no warnings, no codes occurred initially at 56000 mile, has happened 10 or 12 times since then. very scary, im afraid to drive or tow now that dealer mentioned trailer brakes."

Component: LATCHES/LOCKS/LINKAGES

"The contact owns a 2020 GMC Sierra 3500. The contact stated that while towing a trailer, the tailgate unintendedly opened while making a right turn. Due to the failure, the end of the tailgate was ripped in half. Upon investigation, the contact discovered NHTSA Campaign Number: 24V060000 (LATCHES/LOCKS/LINKAGES); which was linked to the failure. The vehicle was taken to a dealer and was informed that the vehicle was not included in the recall. The manufacturer was notified of the failure and referred to the NHTSA Hotline to report the failure. The vehicle was not repaired. The failure mileage was approximately 43,000."

Component: POWER TRAIN

"driving 45 mph westbound i70 at eisenhower tunnel, vefhicle made loud bang, brakes locked up momentarily slowing vehicle to around 25mph. multiple vehicles had to make evasive manuevers to avoid collision. vehicle released after a 15FT skid. pulled over to safety and inspect for damage, tires were falt spotted but no damage was visible. called dealer servcei and was told to make appt and set for diagnostic. service could not replicate or find damage so I was sent on my way and told if it does it again let us know. I am scared to drive this vehicle its unsafe"

Component: STRUCTURE

"There is a current safety recall N232426400 on GMC pickups including the year of my truck. GMC is saying that my VIN is not covered by the recall. However, I have the multi-pro tailgate and it came open about 6 months ago on its own as i was backing up and it caused me to run into my trailer with the tailgate. I put my tailgate up after moving my truck from under my trailer and then when i went to back up somehow the tailgate popped open and i didnt know and it contacted the top of tailgate while it was down."

Component: POWER TRAIN,ENGINE

"Engine Coolant Low error constantly appears. GM Service provider states that engine coolant level is fine, but sensor may be defective."