2024 FORD MAVERICK Safety Overview

Component: SERVICE BRAKES

"Abnormal wear to the brake pads, has always been a slight noise in the wheel from brand new. Now at 10,500 miles being told the brake pads and rotors are shot. I consider this to be extremely abnormal for a well cared for vehicle with very low mileage."

Component: POWER TRAIN,UNKNOWN OR OTHER

"Twice in the last two months the vehicle completely lost the ability to accelerate while driving. While the vehicle was in motion, the accelerator lost all tension and you could put your foot the floor without the vehicle moving. The vehicle still had all other power, including power steering, stereo, lights and power breaks. The first incident occurred last month at low speed in a residential area. The vehicle was able to coast to the sidewalk in front of house. A few minutes later the vehicle started up without issue and was able to be driven home. Afterwards, the vehicle was taken to a local repair show who checked the battery and alternator, but they did not find any issue. Earlier today, the vehicle was being driven at 45-50 miles per hour on a two lane highway without a shoulder. The vehicle started to decelerate while the driver, my daughter, pushed the gas pedal to the floor. The vehicle would not respond and she was luckily able to pull into the driveway of a home. The vehicle did not produce any warning lamps, messages or other symptoms prior to this loss in acceleration. I arrived 4-5 minutes later and the vehicle was able to be driven to home afterwards. We will be taking in to a dealership for a more thorough look at any issues. We would be willing to have the vehicle inspected. This is an astonishing issue to have on a vehicle less than two years old. The loss of power on a freeway could be incredibly dangerous we both the driver of this truck and to other drivers. We live in a hilly area and a safe place to pull off to the side cannot be always guaranteed. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear?"

Component: ELECTRICAL SYSTEM

"Radio sound will not work"

Component: POWER TRAIN

"This Maverick truck has developed a Strong shake upon acceleration. Noticeable lower speeds at acceleration or load. Front passenger side. The tires have been rebalanced, rotated, and even purchased new after irregular front passenger tire wear. 50K Continental tires worn out at 24K. No bent rims, no warped tires. No suspension tie rod play or flex with vehicle suspended. No motor mount play. The axles' dust shields are in-tack, but the wobble is from the passenger side axle. Under warranty but premature wear at 25,000 miles. Feel vibration with wheels spinning and place a stick of lumber as resistance. feel vibration."

Component: SUSPENSION

"The contact owns a 2024 Ford Maverick. The contact received the recall notification letter for NHTSA Campaign Number: 26V340000 (Suspension); however, the part to do the recall repair was not yet available. The contact had no other means of transportation. The local dealer was contacted and confirmed neither the recall remedy nor a loaner vehicle was available. The contact was referred to another dealer. The contact called Crossroads Ford of Sumter (950 N Main St, Sumter, SC 29150), who confirmed no loaner vehicle was available. The manufacturer was contacted but was unable to confirm whether the dealers had loaner vehicles available. The contact had not experienced a failure."

Component: VISIBILITY/WIPER

"Windshield cracked while parked in the sun."

Component: VISIBILITY/WIPER

"Windshield cracked while parking in the sun."

Component: VEHICLE SPEED CONTROL

"I have a Maverick (24 AWD XLT) and this issue has occurred twice. It happened on my vehicle the first time as I was trying to turn left, up an incline, with oncoming traffic - loss of acceleration. There was simultaneously a service light and power train malfunction message that went to my ford app. The vehicle had 5k miles on it. I took it immediate to the dealer. After testing they said the connection at the accelerator was loose (pigtail) and replaced. I just had the same failure occur yesterday (~22k miles) on my way home from work, except I lost acceleration on an inclined on-ramp trying to merge onto the highway. I had just slowed on the ramp to let a semi pass, and am thankful I didn’t try to get ahead of it. It wouldn’t have ended well. Still, I could see traffic jamming behind me, and folks were struggling to get on the highway because of my significantly reduced speed. Losing control of acceleration at a point where it is critical is very dangerous. I’ve never experienced a vehicle failure that felt like it risked my life. For this to occur twice in key moments of acceleration, with less than 25k miles is unsettling. Online there are many similar reports, not sure how this isn’t a recall yet."

Component: ELECTRICAL SYSTEM,SERVICE BRAKES,ENGINE

"I am reporting a recurring safety-critical failure. On two separate occasions, the vehicle has experienced a total electrical and mechanical shutdown while in operation. During these events, the 12V power system fails completely, turning off all instrumentation and, most critically, the electronic power brake assist. This results in a 'hard pedal' condition where the vehicle is nearly impossible to stop without extreme physical force. The first instance occurred at road speeds, forcing an emergency maneuver into a turning lane to avoid traffic. The second instance occurred while reversing, causing the vehicle to lose all braking and propulsion and roll into a busy road resulting in a near-miss collision. The vehicle is currently unsafe to drive as the shutdowns are intermittent and occur without warning."

Component: POWER TRAIN,ELECTRICAL SYSTEM,ENGINE

"I was driving and the vehicle stopped like it was in neutral. I started rolling backwards into a vehicle. He honked and I slammed on breaks. I put flashers on. Waited a bit. Turned off and on and it started. I drove home and called service dept"

Component: POWER TRAIN

"I was driving my vehicle that was warmed up,about 5 miles from my house. I set the cruise control on 50 mph- the vehicle climbed an incline at 50, after the decline started the vehicle down shifted trying to keep 50 mph, but was still over by 3-5 mph. The road flattened out and The next thing i noticed was i was doing 42mph and the transmission was in neutral. I shifted back to drive and didnt use cruise control again that day 3/13/26. I have not notice anything else going on with transmission and have reused cruise control again without an issue. I called the dealer and they have not heard of this or have any technical service bulletins regarding this issues. I was quoted a diagnostic charge if i bring it in. I travel on some busier road and use cruise control often"

Component: VISIBILITY/WIPER

"Windshield washer system failure, recurring problem. Last repaired 18 November 2025. Dealer did not replace the failed components. instead used compressed air to clear the clogged nozzles. As a federal regulated safety system, they should have quarantined the failed components for analysis by Ford engineering. NHTSA complaint number 11700184 was generated. If I can't clear the dirt from my windshield, not only is my safety compromised, but also all who I may encounter in an automobile accident. Not to mention innocent pedestrians."

Component: STEERING,POWER TRAIN,WHEELS

"CV axles failed around 42,000 miles. Purchased new tires due to one being worn. After new tires the front end was shaking on acceleration onto the highway. Vibration stopped once the vehicle got up to speed. The tires were rebalanced but that didn't help. The mechanic found the problem to be the CV axles. Once both were replaced the vibration finally stopped."

Component: POWER TRAIN

"Upon acceleration, the front end vibrates heavily. light pedal depression it isn't quite as noticeable. But medium pressure to gas peddle & it feels like the whole underneath of the engine/ maybe front axle is about to fall apart. the harder the acceleration, the more intense the shaking/vibrating is."

Component: STRUCTURE

"breaking welds on door jams. same as the 20-21 ford escapes that have recall. 52000 miles on my maverick"

Component: POWER TRAIN,ENGINE

"My turbocharger went out 3 times with in a month the dealership is trying there best to fix it but every time they do something with that same system goes wrong. At first it was nothing to bad but lack of power and sounding rough and it was like that the second time the system went out how ever on the 3rd time I was on the highway and when it went out it disabled my crew’s control system and when I bought it back they now say it’s is an electrical concern."

Component: POWER TRAIN

"Front cv axle failure causing severe vibration with acceleration Ford has not fixed yet 40k miles started"

Component: SERVICE BRAKES

"This is a supplemental filing to my existing NHTSA complaint #11715308. I am requesting that the Office of Defects Investigation open a formal Preliminary Evaluation into the 2024 Ford Maverick Hybrid braking system. Since my original complaint, the following has occurred: Ford Motor Company denied my claim on April 2, 2026 through a three-sentence letter from a paralegal at Erskine Law PC in Michigan. The denial addressed none of the evidence submitted including repair orders, fault codes from Ford's own OASIS system, a recorded call proving warranty claim suppression, and a notarized sworn statement. The vehicle now has 107,982 miles. The ABS defect remains unrepaired after four attempts and over 50 days out of service. Active fault codes C052E and U0418 were confirmed in Ford's OASIS system when the vehicle was returned unrepaired on January 28, 2026. Ford has already issued Recall 25V787000 for brake booster ECU overheating causing loss of brake power assist in Maverick vehicles, demonstrating prior corporate knowledge of braking defects in this model line. There are currently 149 brake-related complaints in the NHTSA database for the 2024 Ford Maverick with no open ODI investigation. On [XXX], the braking defect caused a collision (APD Crash Report [XXX], no driver error assigned). I have a notarized sworn statement linking the collision to the unrepaired defect. I have concurrent active complaints with the NM Department of Justice (XXX), BBB AUTO LINE (XXX), FTC (#XXX), CFPB (#XXX), and Ford's internal SpeakUp ethics program (#XXX). I am formally requesting ODI review of the 2024 Maverick Hybrid braking system given the volume of complaints, the existing recall on related models, and Ford's documented refusal to repair my vehicle despite confirmed fault codes in their own diagnostic system. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)"

Component: ELECTRICAL SYSTEM

"The contact owns a 2024 Ford Maverick. The contact stated that while operating the vehicle, the touch screen display was frozen and became inoperable. During the failure, the contact was unable to access the 9-1-1 Emergency feature in the event of an emergency. The contact stated that the vehicle was restarted for the display screen to operate as intended. The vehicle was taken to the local dealer on seven occasions, but the failure was not yet corrected after a software update was performed. The manufacturer was notified of the failure, and the contact was referred back to the local dealer. The failure mileage was 12,000."

Component: STEERING

"When I turn left or right my steering-wheel, slowly at intersections, I hear a loud "click" sound inside my truck's cabin, so loud that I cannot realize where the sound comes out from. My steering performance is smooth, and I cannot feel anything wrong or any shaking, with the steering column. Just ONE loud click sound, every time when I turn slowly. This has been happening since October 2024. Thank you!"