2013 FORD FUSION Safety Overview

Component: SERVICE BRAKES

"While driving home from work. I heard a pop and seen smoke coming from my tire. I pulled over and seen fire behind the wheel. After looking it over the emergency parking brake motor that attaches to the brake caliper was blown apart. The pistons in the caliper pushed so hard against the brake pad that it was bent to a 90 degree angle. Had to replace pads, rotors, and calipers in both sides."

Component: SERVICE BRAKES

"While driving home from work. I heard a pop and seen smoke coming from my tire. I pulled over and seen fire behind the wheel. After looking it over the emergency parking brake motor that attaches to the brake caliper was blown apart. The pistons in the caliper pushed so hard against the brake pad that it was bent to a 90 degree angle. Had to replace pads, rotors, and calipers in both sides."

Component: POWER TRAIN

"The contact owns a 2013 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle failed to respond normally while depressing the brake pedal. Several unknown warning lights were illuminated during the failure. The failure caused the steering wheel to lock up, the brake pedal became extremely firm, and the accelerator pedal became inoperable. Additionally, the exterior lights shut off unexpectedly and the vehicle lost electrical power. The vehicle was safely pulled into a parking lot, and the contact waited for several minutes before restarting the vehicle. The vehicle was restarted; however, 30 seconds after resuming driving the vehicle shut off again. The vehicle was towed to a Ford dealer; however, the mechanics were unable to duplicate the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 179,000."

Component: POWER TRAIN

"The contact owns a 2013 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle failed to respond normally while depressing the brake pedal. Several unknown warning lights were illuminated during the failure. The failure caused the steering wheel to lock up, the brake pedal became extremely firm, and the accelerator pedal became inoperable. Additionally, the exterior lights shut off unexpectedly and the vehicle lost electrical power. The vehicle was safely pulled into a parking lot, and the contact waited for several minutes before restarting the vehicle. The vehicle was restarted; however, 30 seconds after resuming driving the vehicle shut off again. The vehicle was towed to a Ford dealer; however, the mechanics were unable to duplicate the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 179,000."

Component: POWER TRAIN,ENGINE,FUEL/PROPULSION SYSTEM

"Vehicle makes strange sounds from the fuel fill inlet and proceeds to stall shortly after while driving and most of the times fails to restart based on my own research it looks like purge valve issues My safety was put at risk by almost being rear ended multiple times from stalling on the expressway and red lights The problem has not been reproduced yet by the dealer it will be looked at on 07/15/26 The component has not been inspected yet The check engine light illuminated when the issue started"

Component: STEERING

"The steering wheel of my 2013 ford fusion S.E 2.5 Lm was tightly connected to the steering system until now. It has start wobbling over time and the problem have greatly increased as of 05\31\2026. I fear that if I can’t this problem fixed soon the whole steering wheel will disconnect one day. When I told a mechanic about the problem he told me there was a recall put out by Ford Fusion Motors on many Ford Fusion Sedans for similar issues. I truly believe my car had to miss the recall."

Component: STEERING

"The steering wheel of my 2013 ford fusion S.E 2.5 Lm was tightly connected to the steering system until now. It has start wobbling over time and the problem have greatly increased as of 05\31\2026. I fear that if I can’t this problem fixed soon the whole steering wheel will disconnect one day. When I told a mechanic about the problem he told me there was a recall put out by Ford Fusion Motors on many Ford Fusion Sedans for similar issues. I truly believe my car had to miss the recall."

Component: VEHICLE SPEED CONTROL,UNKNOWN OR OTHER,ENGINE

"The vehicle goes into limp mode without warning no matter the speed. cylinder head temp sensor is not applicable on this 1.6 engine model. The coolant over temp light illuminates with or without the car running. coolant temperature sensor was replaced and indicates no faults to the obd. the coolant level and temperature is within spec."

Component: VEHICLE SPEED CONTROL,UNKNOWN OR OTHER,ENGINE

"The vehicle goes into limp mode without warning no matter the speed. cylinder head temp sensor is not applicable on this 1.6 engine model. The coolant over temp light illuminates with or without the car running. coolant temperature sensor was replaced and indicates no faults to the obd. the coolant level and temperature is within spec."

Component: STEERING,LANE DEPARTURE

"While driving a 2013 Ford Fusion Hybrid Titanium (approximately 157,000 miles), the Electronic Power-Assisted Steering (EPAS) system suddenly failed without warning during heavy rain in Philadelphia, PA. I was driving near the riverfront area by [XXX] when the steering immediately became extremely stiff and difficult to turn. No prior warning lights or steering-related symptoms were present before the failure. Due to wet road conditions and the sudden loss of steering assist, I temporarily lost the ability to maneuver the vehicle normally and nearly collided with roadside structures near the river. Considerable physical force was required to maintain directional control and safely move the vehicle. This created an immediate safety hazard to myself and nearby traffic. The vehicle has not been involved in a crash, but the failure created a near-miss situation. My VIN currently shows no open recall for this issue, despite similar steering-system failures reported in comparable Ford vehicles using EPAS. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)"

Component: STEERING,LANE DEPARTURE

"While driving a 2013 Ford Fusion Hybrid Titanium (approximately 157,000 miles), the Electronic Power-Assisted Steering (EPAS) system suddenly failed without warning during heavy rain in Philadelphia, PA. I was driving near the riverfront area by [XXX] when the steering immediately became extremely stiff and difficult to turn. No prior warning lights or steering-related symptoms were present before the failure. Due to wet road conditions and the sudden loss of steering assist, I temporarily lost the ability to maneuver the vehicle normally and nearly collided with roadside structures near the river. Considerable physical force was required to maintain directional control and safely move the vehicle. This created an immediate safety hazard to myself and nearby traffic. The vehicle has not been involved in a crash, but the failure created a near-miss situation. My VIN currently shows no open recall for this issue, despite similar steering-system failures reported in comparable Ford vehicles using EPAS. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)"

Component: UNKNOWN OR OTHER

"A power steering assist fault warning popped up on my vehicle after starting my car. It’s now extremely difficult to turn the wheel. There was no previous indication that there was an issue with the power steering."

Component: UNKNOWN OR OTHER

"A power steering assist fault warning popped up on my vehicle after starting my car. It’s now extremely difficult to turn the wheel. There was no previous indication that there was an issue with the power steering."

Component: UNKNOWN OR OTHER

"No incident - back up camera issue. Glitches often, then goes black and does not work. Have also received error messages indicating "Camera is unavailable. Please contact your dealership." Has happened a few times in the past but is now happening more often"

Component: UNKNOWN OR OTHER

"No incident - back up camera issue. Glitches often, then goes black and does not work. Have also received error messages indicating "Camera is unavailable. Please contact your dealership." Has happened a few times in the past but is now happening more often"

Component: STEERING

"The contact owns a 2013 Ford Fusion. The contact stated that while steering the vehicle at various speeds, an abnormal, grinding sound would emit from the vehicle without warning. Upon investigation, the contact discovered that the vehicle was NHTSA Campaign Number: 23V162000(SERVICE BRAKES, HYDRAULIC). The contact made an appointment and spoke with the dealer about the failure. The contact was informed by a dealer mechanic that the grinding noise was not related to brake system but the Electric Power-Assisted Steering (EPAS). Upon further investigation, the contact discovered NHTSA ID Number: 15V250000(Steering) which the contact linked to the failure. The manufacturer was notified of the failure and the contact was informed that the vehicle was not included in the recall. The vehicle was not repaired. The failure mileage was approximately 210,000."

Component: STEERING

"The contact owns a 2013 Ford Fusion. The contact stated that while steering the vehicle at various speeds, an abnormal, grinding sound would emit from the vehicle without warning. Upon investigation, the contact discovered that the vehicle was NHTSA Campaign Number: 23V162000(SERVICE BRAKES, HYDRAULIC). The contact made an appointment and spoke with the dealer about the failure. The contact was informed by a dealer mechanic that the grinding noise was not related to brake system but the Electric Power-Assisted Steering (EPAS). Upon further investigation, the contact discovered NHTSA ID Number: 15V250000(Steering) which the contact linked to the failure. The manufacturer was notified of the failure and the contact was informed that the vehicle was not included in the recall. The vehicle was not repaired. The failure mileage was approximately 210,000."

Component: ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM

"My 2013 Ford Fusion equipped with the 1.6L EcoBoost engine started blowing thick white smoke (Burning Coolant) while I was driving on the freeway. Engine coolant was leaking and my card died right there, that had blown the head gasket. I received no warning, no message. This was an incredibly dangerous situation because I was on the freeway and was forced to stop immediately. Ford Motor Company has refused to include my vehicle’s VIN in the applicable recall programs despite my vehicle experiencing the same issues described in NHTSA recalls 12V551000 (Ford Campaign 12S41) and 17V209 (Ford Campaign 17S09) The recalls identify issues involving coolant loss, overheating, insufficient warning of coolant loss, potential engine damage, cylinder head damage, and the risk of engine compartment fire. My vehicle exhibited these same symptoms and consequences which can be confirmed by the autobody shop where it was evaluated. The purpose of these recalls was to address a known safety concern involving the 1.6L EcoBoost engine cooling system. Despite this, when I contacted Ford and requested assistance and asked that my VIN be added to the recall population, Ford denied my request and stated that my vehicle was not included. I believe this decision fails to address the fact that my vehicle experienced the same defect and safety risk identified in the recall documents. The safety issue is not limited to the VINs currently listed in the recall population; rather, my vehicle demonstrates the same failure mode that prompted the recalls. My concern is that vehicles equipped with the same engine and experiencing the same defect may continue to pose a safety risk to drivers and passengers. A coolant loss event and overheating condition can result in significant engine damage, sudden loss of vehicle operation, costly repairs, and the potential for an engine compartment fire. respectfully request that this matter be reviewed and that Ford be required to re-evaluate their decision."

Component: STEERING

"I was driving the vehicle and a warning message came on related to the power steering module not functioning correctly. Immediately after the steering column locked up and was stiff and to tough to continue driving. I looked into repairs and notice a recall # 19S26 was issued in 2019 with my specific vehicle in the list by year, brand and model for the exact problem described. When I contacted Ford, they advised me that my VIN # was not included in the recall. Wanted to file complaint due to the lack of coverage Ford offers for cars specifically covered under the recall."

Component: STEERING

"I was driving the vehicle and a warning message came on related to the power steering module not functioning correctly. Immediately after the steering column locked up and was stiff and to tough to continue driving. I looked into repairs and notice a recall # 19S26 was issued in 2019 with my specific vehicle in the list by year, brand and model for the exact problem described. When I contacted Ford, they advised me that my VIN # was not included in the recall. Wanted to file complaint due to the lack of coverage Ford offers for cars specifically covered under the recall."

Component: STEERING

"The steering locked up while driving. I was unable to turn the steering wheel. My self and my brother were in the vehicle. At this time, I am contacting the dealer to look at the unit. It will not turn and is stuck in my driveway. I am being told the electronic steering rack may have failed. Why does this not break way and allow some turning like the old hydraulic models? If I had been driving highway speeds, this would have been a serious accident."

Component: STEERING

"The steering locked up while driving. I was unable to turn the steering wheel. My self and my brother were in the vehicle. At this time, I am contacting the dealer to look at the unit. It will not turn and is stuck in my driveway. I am being told the electronic steering rack may have failed. Why does this not break way and allow some turning like the old hydraulic models? If I had been driving highway speeds, this would have been a serious accident."

Component: ENGINE

"The transmission shift cable bushing at the transmission end of the shifter cable has completely degraded and detached, which is a component available for inspection upon request. This failure caused a significant safety risk as the gear shifter inside the cabin moved freely while the transmission remained in its last gear, creating an immediate rollaway risk and preventing the vehicle from being shifted into Park. The safety of others was put at risk because the vehicle could not be secured and could have moved in an unintended direction. This specific problem has been confirmed by a Ford dealership, yet the dealer refused to perform the necessary repair under Recall 22S43 (NHTSA Campaign 22V413), claiming the VIN was not covered despite the vehicle exhibiting the exact failure and being within the recalled model year and assembly plant range. Prior to this total failure, there were no warning lamps or messages, though the instrument cluster occasionally showed a gear position that did not match the physical shifter before the bushing finally disintegrated. The vehicle has not yet been inspected by the manufacturer or insurance representatives."

Component: ENGINE

"The transmission shift cable bushing at the transmission end of the shifter cable has completely degraded and detached, which is a component available for inspection upon request. This failure caused a significant safety risk as the gear shifter inside the cabin moved freely while the transmission remained in its last gear, creating an immediate rollaway risk and preventing the vehicle from being shifted into Park. The safety of others was put at risk because the vehicle could not be secured and could have moved in an unintended direction. This specific problem has been confirmed by a Ford dealership, yet the dealer refused to perform the necessary repair under Recall 22S43 (NHTSA Campaign 22V413), claiming the VIN was not covered despite the vehicle exhibiting the exact failure and being within the recalled model year and assembly plant range. Prior to this total failure, there were no warning lamps or messages, though the instrument cluster occasionally showed a gear position that did not match the physical shifter before the bushing finally disintegrated. The vehicle has not yet been inspected by the manufacturer or insurance representatives."

Component: ELECTRICAL SYSTEM,UNKNOWN OR OTHER

"“Temporary loss service climate system ford fusion 2013” Ac turns on and off windows lock up when ac turns off. everything freezes up! I see online this should be a recall a lot of ford owners having the same problem!"

Component: STEERING

"Power steering / power steering assist failure. Complete loss of power steering"

Component: ELECTRICAL SYSTEM,UNKNOWN OR OTHER

"“Temporary loss service climate system ford fusion 2013” Ac turns on and off windows lock up when ac turns off. everything freezes up! I see online this should be a recall a lot of ford owners having the same problem!"

Component: STEERING

"Power steering / power steering assist failure. Complete loss of power steering"

Component: SERVICE BRAKES

"Brakes went out while driving. Brake fluid reservoir is full."

Component: SERVICE BRAKES

"Brakes went out while driving. Brake fluid reservoir is full."

Component: UNKNOWN OR OTHER,ENGINE

"1. My car began to produce white smoke after a burning smell. Then caught fire under the hood in engine area. The car is buried in snow/ice, not available to access. 2. The car caught fire. 3. The problem has not been reproduced nor confirmed by anyone (dealer/independent service center) 4. No, due to weather conditions. (Blizzard) 5. Only the burning smell and white smoke."

Component: AIR BAGS,ELECTRICAL SYSTEM,SERVICE BRAKES

"See attached document for complaint."

Component: AIR BAGS,ELECTRICAL SYSTEM,SERVICE BRAKES

"See attached document for complaint."

Component: STEERING,ELECTRICAL SYSTEM,AIR BAGS

"The power steering module/rack, passenger side air bag Safety is a risk due to steering not working properly/ seat belt constantly locking Yes Yes others inspected Seat belt sensor has been on several months Service steering assist/Lane keep system malfunction service required and steering assist fault - all came on when it got cold and steering won’t work now"

Component: ELECTRICAL SYSTEM,STRUCTURE,ENGINE

"I own a 2013 Ford Fusion SE with a 1.6L EcoBoost engine. Prior to the incident, the vehicle displayed a “Check Charging System” warning and the engine overheated. After parking the vehicle and shutting it off, a fire started under the hood in the engine compartment. The fire occurred shortly after the overheating warning and while the vehicle was not running. The fire appeared to originate in the engine bay area and caused significant damage. There were no prior accidents or modifications to the vehicle."

Component: UNKNOWN OR OTHER

"Vehicle: 2013 Ford Fusion Mileage: ~165,000 miles Issue Type: Engine stalls / loss of power My 2013 Ford Fusion has experienced intermittent engine stalling and hesitation since early ownership. The vehicle will stall or “putter” when slowing down or coming to a stop, often without warning. When this occurs, the engine shuts off and the vehicle must be put into park and restarted. Restarting is sometimes delayed or hesitant. This issue occurs without any warning lights or diagnostic trouble codes appearing on the dashboard, making it difficult for dealerships and mechanics to diagnose. The problem has persisted for years and has occurred multiple times under normal driving conditions. This defect presents a serious safety risk, as the vehicle can lose power unexpectedly while in traffic, at intersections, or during braking. Loss of engine power in these situations creates a high risk of collision. The vehicle has been inspected multiple times, including by dealerships, but the issue could not be identified due to the absence of fault codes. This appears to be a design or component defect that does not reliably trigger diagnostic warnings. I am reporting this as a safety-related defect involving unexpected engine stalling and loss of power. The date I marked you asked below is the most current but as I stated it’s been happening since a month after purchasing the car brand new."

Component: ENGINE AND ENGINE COOLING

"The contact owns a 2013 Ford Fusion. While the contact's wife was driving at an undisclosed speed, the check engine warning light illuminated, and the engine overheated. The contact was informed that there was a burning odor coming from the vehicle. The contact was called for help. The contact arrived at the location and inspected under the hood, and became aware that the coolant level was low. The coolant reservoir was refilled, and the contact became aware that coolant and oil were leaking onto the manifold. The vehicle was driven to the residence with the persistent burning odor. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The dealer was made aware of the failure but provided no assistance. The contact was advised to bring the vehicle to the dealer for diagnostic testing. The contact referenced an unknown recall with a similar failure; however, the VIN was not under recall. The contact stated that the oil and coolant leaking onto the manifold was a fire hazard. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 190,000."

Component: UNKNOWN OR OTHER

"Rear view camera intermittently works. Blackout when reversing. Car is in reverse camera starts then stops"

Component: POWER TRAIN

"The car is experiencing jerks between gear shifts. Almost hit another car due to this car movement when it shifts between gears"

Component: EXTERIOR LIGHTING

"Turn signal prematurely cancels intermittently, in middle of turn or prior to starting turn. This is after the signal stalk switch has been locked into the continuous on position, not the momentary position. The slightest movement of the steering wheel back away from the direction of turn will induce this. Not a full 1/8 of a turn back, but a very minute amount, as little as 1 or 2 degrees of steering movement. This is a known issue by the manufacturer, as they have service bulletin instructions for dealership technicians to reprogram the steering column signal switch, however, this repair is cost prohibitive at dealership rates. It is a safety concern, as the signal sometimes cancels without immediate driver awareness, as attention is being focused outside. This should be a recall repair covered by the manufacturer."

Component: VISIBILITY/WIPER

"The rear view camera intermittently stops working, giving a message “camera unavailable” in a black screen. This has happened many times during use and caused near misses during vehicle reversing."

Component: UNKNOWN OR OTHER

"UNKNOWN - I was driving the car on a highway, there were no alerts and my engine light was not on, and my car started smoking and within 5 minutes my car was completely on fire. After the fire was put out, the whole front of the car was gone and then engine looked melted."

Component: STEERING

"A couple of weeks ago My Steering wheel locked up and the codes were reset which unlocked the wheel so i was able to turn it. Mechanic said it was moisture getting to the part and then the power steering light came on & it became Hard to turn the steering wheel while driving. There was no indication of a issue before it started."

Component: ENGINE AND ENGINE COOLING

"The contact owns a 2013 Ford Fusion. The contact stated that upon starting the vehicle, there was abnormal white smoke coming out of the tailpipe. The contact stated that upon inspecting the oil dipstick, the contact noticed that there was coolant in the oil, and the contact also noticed that there was a small amount of oil in the coolant reservoir. The contact related the failure to NHTSA Campaign Number: 17V209000 (Engine and Engine Cooling), for which the VIN was included. The dealer was contacted and informed the contact that the recall repair would be performed on the vehicle; however, the contact was concerned that the recall remedy would not correct the failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 109,200."

Component: UNKNOWN OR OTHER

"My rear camera will go out while in reverse. Sometimes boxes appear on the screen or it will be completely black."

Component: ENGINE

"Vehicle ran very well, however engine caught fire while exiting highway. Insurance adjuster states common issue with Ford EcoBoost engines. Reported to Ford whom dismissed issue of engine fire"

Component: UNKNOWN OR OTHER

"My car was parked in my driveway. I realized that I didn't have my key on me. So I quickly ran in the house to get my key. I went outside to find my car rolling down my driveway into my neighbor's brick house. My 11 year old was messing with the gear shift from the back seat and was able to change the gear to neutral with no brake engaged and no key in the ignition. When I went to the dealership, an employee was able to tell me that it was a bad shifter cable bushing. I checked to see if there is a recall and there was for our year, make, and model; unfortunately, our VIN is now registered under the recall."

Component: SUSPENSION

"I have replaced my struts and shocks three times and I am still having trouble with my stability trac"

Component: ELECTRICAL SYSTEM,WHEELS,FUEL/PROPULSION SYSTEM

"1. After vehicle is given gas it won’t crank. 2. Tire sensors won’t turn off. Even with brand new tires and mounts. 3. Random electrical malfunctions. (Flickering dash lights, delayed engine start after turning the key, light bouncing back and forth between gears, etc.)"

Component: STEERING,ELECTRICAL SYSTEM,ENGINE

"Unknown and it's whole electrical system is failing and constantly keeps shutting the car off saying no key detected and strands me more places than I can count it's stalled out in the middle of the road and said no key detected and I had to wait for it to basically let me start the car back up after like being shut off for 20 mins or if I unhooked the battery and hooked it back up then it would start and only go for a day or so and the heat only works if it's raining outside"