2022 FORD EXPLORER Safety Overview

Component: VEHICLE SPEED CONTROL,UNKNOWN OR OTHER,FORWARD COLLISION AVOIDANCE

"I was in a middle school parking lot attempting to park my vehicle. My foot was not on the accelerator, and my foot was light depressed on the brake pedal as I was attempting to park the car prior to school release. The vehicle suddenly accelerated at a high rate, with no indicators on the dashboard that there was a mechanical/electrical issue. I had to swerve to avoid colliding with a parked vehicle and abruptly applied the brake pedal, which depressed into the floor board. This incident would have injured a child or parent at school release had I not arrived prior to end of day release. To summarize: Date/time: October 21, 2026 - 2:55 p.m. Vehicle: 2022 Ford Explorer Platinum Auto Hold: OFF Vehicle was in Drive and moving forward at parking/crawl speed. Accelerator pedal was not depressed and my foot was not near the accelerator. Vehicle suddenly accelerated forward with substantial force, consistent with heavy/full accelerator input. No warning lights or messages appeared before, during or immediately after the event. I had to abruptly steer away to avoid colliding with another vehicle."

Component: UNKNOWN OR OTHER

"Right control arm snapped while reversing into a parking spot"

Component: FUEL/PROPULSION SYSTEM

"My mom was helping me strap my 3 year old and baby in the car seats of my 2022 ford explorer and said my car smelled like raw gas. I didn’t realize it because I was so used to it. As soon as she said something I did smell it. I had been getting headaches while driving but didn’t think much about it. I took it to the ford dealership and it needed a new purge valve and was causing the fuel in the cab. It could’ve ended up way worse if my mom hadn’t smelled the fuel and was there to help me strap the kids in."

Component: SUSPENSION

"Car was purchased brand new from Ford Dealership in May 2023. In September 2026, brought car in for 20,000 mile service at Ford Dealership in San Jose, California to discover that both rear shock absorbers are already worn and shocks are leaking. Dealer recommended that they needed to be replaced. Upon research, this issue has very common with 2022 Ford Explorers (all trims). I believe this is a defective issue that should be investigated. No check engine or warning lights ever came up due to this issue."

Component: SUSPENSION

"While operating the vehicle, a loud clunk occurred, followed by a grinding noise. I stopped the vehicle immediately. Upon exiting, I observed the rear driver‑side tire positioned at an abnormal angle. Inspection underneath the vehicle revealed a fractured rear control arm. This failure is consistent with recall 23S55, which applies to Ford Explorers manufactured between 6/25/21 and 7/6/22. My vehicle’s build date is July 2022, which falls within the affected production window. The damage is clearly consequential to the control arm failure."

Component: ELECTRICAL SYSTEM,EXTERIOR LIGHTING,SEATS

"#1st- The AC goes on and off and now the AC no longer works it only blows out hot air ,earlier but it turns on and off by itself #2- the lights flicker #3- the seats move by themselves and just today Sunday [XXX] the seat having to see what all the way back by yourself thinning my [XXX] son's legs against his car seat thank [XXX] my fiance was in the passenger seat when it happened and had to lift it up and then it clicked and started moving back up by itself the dealership Jim Hudson dealership did 10 different service calls for electrical issues and did not report it to me once we plan on going in there and figuring out because I do not want this truck that's dangerous for my life as well as my [XXX] and my [XXX] turn the process of selling me the vehicle that did not tell me person that this vehicle has had electrical issues from day one with only 8000 miles on it was the first report of the electrical issue I had to look it up on the Ford app and found out that it's been serious 10 different times what's the dealership did not tell me in person first issue with this truck as nf electrical was INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)"

Component: ENGINE,FUEL/PROPULSION SYSTEM

"Pursuant to recall 24S55 engine valve crack causing catastrophic damage. Misfire codes given and addressed independently giving brief changes however car reverted back to "limp" mode on major Dallas hwy causing extreme safety issues. Conditions confirmed by Freedom Ford Greenville Texas. Estimated replacement costs exceeds 14k."

Component: UNKNOWN OR OTHER,VISIBILITY/WIPER

"The rearview backup camera on my vehicle has malfunctioned and does not reliably display an image when the vehicle is placed in reverse. The manufacturer sent an official Customer Satisfaction Program notice acknowledging this as a known defect and offering a one-time no-charge replacement, stating parts availability was limited only until October 2026. When I brought the vehicle to an authorized dealership for the repair, the dealership was unable to complete it due to lack of parts and told me parts would not be available until February 2027, several months beyond what the manufacturer's own notice stated. This creates an ongoing safety risk since I cannot reliably see behind the vehicle while backing up, increasing the risk of collision with pedestrians, other vehicles, or objects. The vehicle has been inspected by the dealership's service department, which confirmed the camera issue during a service visit but could not resolve it due to parts unavailability. There were no dashboard warning lights specifically tied to this defect; the camera simply fails to display a reliable image when reverse is engaged. The component is available for inspection upon request. I have not yet received a corrected repair timeline from the manufacturer despite formally raising this issue."

Component: UNKNOWN OR OTHER

"I purchased a 2022 Ford Explorer XLT in March 2026 with approximately 19,500 miles on the vehicle. While driving, I suddenly heard a loud noise above me. I looked up and discovered that a clip from the panoramic sunroof shade had broken. I took the vehicle to the dealership for inspection and was informed the repair would cost approximately $500. While waiting at the dealership, another customer arrived with the same problem on their Ford Explorer. This is a safety concern because the unexpected noise distracted me while I was driving and caused me to look away from the road to determine what had happened. A component of the panoramic sunroof shade should not fail under normal use, especially at such low mileage."

Component: POWER TRAIN

"Rear CV axel splines are causing an audible sound when shifting from park to reverse or park to drive. It also occurs when the car goes from accelerating to coasting and then back to accelerating. The sound has gotten louder and is more frequent within the last 2 months. Ford is stating this noise is otherwise not harming the CV Axel or the splines therein."

Component: FUEL SYSTEM, GASOLINE

"The contact owns a 2022 Ford Explorer. The contact stated that while his wife was driving 10 MPH with children inside the vehicle, while depressing the accelerator pedal, the vehicle hesitated and loss power. While attempting to restart the vehicle, the vehicle failed to respond. A dealer was contacted. No warning light was illuminated. The vehicle was towed to a dealer where it was diagnosed and determined that the fuel pump needed to be replaced. The vehicle was not repaired. The contact associated the failure with NHTSA Campaign Number: 25V455000 (FUEL SYSTEM, GASOLINE); however, the VIN was not included in the recall. The vehicle was repaired. The contact stated that the failure had occurred on several occasions. The manufacturer was notified of the failure and informed the contact that a representative would return the phone call. The approximate failure mileage was 66,000."

Component: ENGINE

"Exhaust manifold turbo charged cracked while driving. Exposing everyone in the vehicle to raw exhaust inside the vehicle every time it is driven. The replacement part is back ordered until September 16th from the dealership. I was told this is an extremely common issue with ford explorers. I don’t understand how this part is not recalled. It has slowly gotten worse and worse. No warning lamps came on. You can hear the engine or manifold rattling/ticking while the vehicle is running. The vehicle is available for inspection. I brought the vehicle to a repair shop called MIDAS. Where I was told exactly what was wrong with it. The problem is reproduced every single time the vehicle is on. The replacement part is also not covered under fords “emissions warranty”. Even though it is part of the emissions."

Component: POWER TRAIN,ELECTRICAL SYSTEM,ENGINE

"RECALL COMPLIANCE & SAFETY DEFECT DESCRIPTION: The vehicle was transported via roadside assistance to a licensed manufacturer dealership due to severe engine overheating under an active manufacturer safety recall. Service personnel systematically modified intake paperwork to alter the true mechanical state upon arrival, removing safety recall and towing documentation. Intake files were falsified with the notation stating that the customer reported a bad battery, executed solely to evade mandatory factory safety recall tracking protocols and obscure dealer liability for subsequent failures. UNAUTHORIZED SHOP-FLOOR HAZARDS & MECHANICAL DAMAGE: Following custody transfer, shop technicians induced severe physical damage to the vehicle's twin-turbocharger assembly, resulting in a snapped turbo stud and a torn engine air filter. The vehicle was subsequently operated on public roads by shop personnel for 75 to 80 unauthorized miles under active engine overheating conditions without correcting thermal or safety recall failures, creating an immediate risk of catastrophic engine block structural cracking. The safety failures triggered 13 critical system fault codes across powertrain, electrical, and battery systems, which went entirely unaddressed while the shop attempted to compel payment under an altered repair estimate. CYBER SABOTAGE OF OUTBOUND SAFETY TELEMATICS: To actively obstruct diagnostic tracking and safety verification, shop staff executed a forced remote network reset of the vehicle's cellular modem. This reset deliberately severed user profile access and entirely deactivated the outbound telematics pipeline to systematically block the outbound transmission of the 13 powertrain and thermal fault messages to the user and manufacturer databases."

Component: ENGINE

"The check engine light was on. A Ford dealership diagnosed the issue as a coolant intrusion manufacturer defect. There are a number of safety concerns associated with this issue. The primary danger of the coolant intrusion defect is catastrophic engine failure. Severe overheating, internal damage, misfires, fire hazard and oil contamination. There are no active recalls\campaigns\TSB for 2022 Ford Explorer XLT 2.3L EcoBoost engine. The car is available for inspection. Although, the vehicle has not been inspected by the manufacturer, police or insurance agent, the issue was presented to Ford and a claim was submitted to the insurance company that services my Mechanical Breakdown Insurance. So far the insurance company is not authorizing the work without an engine breakdown. They are not excepting the P0300 and P0316 code or the results of a barascope and other test. The Ford corporation will not provide a written statement that confirms the dealerships diagnosis is accurate. Some doctrine that states the engine long block had to be replaced to fix the coolant intrusion defect. Ford has recalled coolant intrusion issues on other engine models. I requested a formal Tiered Goodwill Review based on the Miller v. Ford framework and resolution terms. Since the service center’s portal does not display an automatic, VIN-specific internal factory code for a long block replacement. The request was denied. While the Miller v. Ford litigation established corporate accountability for structural block and cylinder coolant intrusion faults in 2.0L blocks, my 2022 2.3L engine shares a highly similar open-deck block geometry and suffers from the exact same systemic coolant failure. Furthermore, Ford has acknowledged manufacturing line coolant and block defects on 2021–2023 2.3L engines through Customer Satisfaction Programs 23B42 and 23B08. Yet there are no recalls associated with my VIN."

Component: ELECTRICAL SYSTEM,VISIBILITY/WIPER

"Rear wiper was working intermittently now it does not work at all. I notice campaign 26S14 (NHTSA Campaign 26V117) but my vin is not included. Even though I have the same problem"

Component: STRUCTURE,VISIBILITY/WIPER

"2022 Explorer ST. Panaramic sun shade does not retract if sun roof is opened nor stay up at the ceiling when sun roof is closed. Sun shade sags down touching my head and just flops around if driving with a window open rendering the rear view mirror useless. Can't see out the rear window."

Component: VISIBILITY/WIPER

"The headliner on the sunroof panel began sagging to the point that visibility is compromised between the driver and rear of the vehicle. This is a common failure on these vehicles, and very expensive to repair. It is obviously caused by the design of the sunroof shade cover assembly."

Component: UNKNOWN OR OTHER

"Safety Defect: Moonroof Sunshade Sags and Obstructs Rearward Driver Visibility I am reporting a safety concern involving the fabric sunshade/moonroof cover in my 2022 Ford Explorer. When the moonroof fabric sunshade is closed/engaged, the fabric sags substantially downward from the roof. The sag is severe enough that the sunshade extends well below its intended position and can obstruct the driver’s view through the rear window. This is not simply a cosmetic issue. When the sunshade is engaged, the sagging fabric creates a significant obstruction to rearward visibility from the driver’s seating position. This can prevent the driver from seeing vehicles, pedestrians, or other objects behind the vehicle while driving. The attached photograph shows the condition from inside the vehicle. The fabric can be seen hanging substantially below the surrounding headliner and roof structure. The amount of sag is sufficient to interfere with the driver’s line of sight toward the rear of the vehicle. The driver should not have to operate the vehicle with the moonroof shade open simply to maintain adequate rearward visibility. The purpose of the shade is to block sunlight while remaining within the designed roof area; it should not hang down into the passenger compartment far enough to obstruct the driver’s view. Because this condition can directly affect the driver’s ability to observe traffic behind the vehicle, I believe it presents a potential motor-vehicle safety hazard and should be investigated as a possible defect affecting the moonroof/sunshade assembly. Vehicle: 2022 Ford Explorer I request that NHTSA investigate whether this condition is occurring in other Ford Explorer vehicles and whether the design, material, mounting, or tensioning system of the moonroof sunshade can cause it to sag and obstruct rearward visibility."

Component: ENGINE,FUEL/PROPULSION SYSTEM

"I have a loss of fuel pressure and flow from the fuel tank due to fuel pump failure. Sometimes my engine stalls while driving, and when I go to fill my tank with gas, the engine will not start. I have to engage it for about 15 minutes before it will start. My check engine light comes on, and I will get the low fuel indicator light. But more importantly I cannot pass inspection. I need my car, I am a health care professional I have contacted my dealership, a Ford Motor company representative, and the only response and action I get in return is that they are still waiting on the part to come in. It has been over a year. I need this recall to be completed as indicated by Ford Motor corporation and its dealerships, please. My contact information is [XXX], [XXX], my email is [XXX]. My vehicle is the 2022 FORD EXPLORER, VIN: [XXX], my Cell number is [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)"

Component: FUEL SYSTEM, GASOLINE,ENGINE

"The contact owns a 2022 Ford Explorer. The contact stated that while driving at an undisclosed speed, there was an abnormal sound coming from the vehicle before the engine seized. The check engine warning light was illuminated. The vehicle restarted after several attempts and was driven to the residence. The contact's minor grandchild was an occupant in the vehicle when the failure occurred. The contact stated that the temperature was extremely hot outside when the failure occurred. The failure was a persistent failure. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The manufacturer was not made aware of the failure. The failure mileage was approximately 60,000."