2023 FORD EXPEDITION Safety Overview

Component: STRUCTURE

"The contact owns a 2023 Ford Expedition. The contact received notification of NTHSA Campaign Number 26V368000 (Structure); however, the part needed for the recall repair was not yet available. The contact stated that while reaching to pick up a debit card, the center console cup holder chrome plating, which had peeled off and stood upright, sliced the contact's pinky finger on her right hand. The deep gash required medical attention. No further information was available. The contact associated the injury with the recall. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure and informed that the medical expenses would be covered. The failure mileage was approximately 90,691."

Component: STRUCTURE

"The contact owns a 2023 Ford Expedition. The contact received notification of NTHSA Campaign Number 26V368000 (Structure); however, the part needed for the recall repair was not yet available. The contact stated that while reaching to pick up a debit card, the center console cup holder chrome plating, which had peeled off and stood upright, sliced the contact's pinky finger on her right hand. The deep gash required medical attention. No further information was available. The contact associated the injury with the recall. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure and informed that the medical expenses would be covered. The failure mileage was approximately 90,691."

Component: UNKNOWN OR OTHER

"On June 10, 2026, I attempted to enter my vehicle through the driver's door. The power running board was set to the "Automatic" position but failed to deploy when the driver's door was opened. I stepped toward the vehicle expecting the running board to be extended, as it normally would be, but it was not. As a result, I lost my footing and fell. The fall caused a nondisplaced fracture of my left ring finger, which required evaluation at an urgent care facility, X-rays, treatment by a hand specialist, and immobilization in a custom splint. Surgery was considered due to concern for possible rotational deformity of the finger. The running board never deployed during the incident. There were no warning lights, warning messages, or other indications that the running board would not operate. To my knowledge, the problem had not occurred previously. The vehicle has not yet been inspected by the manufacturer or dealer to determine the cause of the running board failure. The running board system is available for inspection upon request. I am submitting this report because the unexpected failure of the automatic running board created a fall hazard that resulted in a documented injury. I am concerned that a similar failure could cause more serious injuries to other drivers or passengers, particularly children, older adults, or anyone with mobility limitations."

Component: ELECTRICAL SYSTEM

"The contact owns a 2023 Ford Expedition. The contact stated that while parked and turned off, the vehicle suddenly started independently. The contact turned off the vehicle manually. The contact stated that the failure occurred twice. The dealer was contacted, and an appointment was scheduled; however, the vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was 22,080."

Component: UNKNOWN OR OTHER

"On June 10, 2026, I attempted to enter my vehicle through the driver's door. The power running board was set to the "Automatic" position but failed to deploy when the driver's door was opened. I stepped toward the vehicle expecting the running board to be extended, as it normally would be, but it was not. As a result, I lost my footing and fell. The fall caused a nondisplaced fracture of my left ring finger, which required evaluation at an urgent care facility, X-rays, treatment by a hand specialist, and immobilization in a custom splint. Surgery was considered due to concern for possible rotational deformity of the finger. The running board never deployed during the incident. There were no warning lights, warning messages, or other indications that the running board would not operate. To my knowledge, the problem had not occurred previously. The vehicle has not yet been inspected by the manufacturer or dealer to determine the cause of the running board failure. The running board system is available for inspection upon request. I am submitting this report because the unexpected failure of the automatic running board created a fall hazard that resulted in a documented injury. I am concerned that a similar failure could cause more serious injuries to other drivers or passengers, particularly children, older adults, or anyone with mobility limitations."

Component: UNKNOWN OR OTHER

"Component/System Malfunction & Availability: The vehicle's Air Conditioning (A/C) system failed completely. The primary component that failed is the REAR A/C compressor/evaporator core. The vehicle and its NEW and REPLACED components are available for inspection upon request. The original damaged components are with the dealership. ​Safety Risk: The sudden and total loss of climate control occurred during extreme weather conditions. This caused an immediate and rapid rise in cabin temperature to unsafe levels, posing a severe risk of heat exhaustion, dehydration, and heatstroke, particularly for vulnerable passengers. Furthermore, the loss of the A/C system compromised the vehicle's ability to clear window fogging and condensation, rapidly reducing visibility and creating an immediate crash hazard. ​Diagnosis & Inspection Status: The issue has been reproduced and officially confirmed by an authorized dealer/independent service center. However, the vehicle and the failed components have not yet been inspected by the manufacturer, police, or insurance representatives. ​Prior Symptoms & Warning Signs: There were no warning lamps, error messages, or diagnostic trouble codes displayed on the dashboard prior to the failure. UNKNOWN exactly when the internal component degradation began, but the total failure occurred suddenly without prior symptoms."

Component: UNKNOWN OR OTHER

"Component/System Malfunction & Availability: The vehicle's Air Conditioning (A/C) system failed completely. The primary component that failed is the REAR A/C compressor/evaporator core. The vehicle and its NEW and REPLACED components are available for inspection upon request. The original damaged components are with the dealership. ​Safety Risk: The sudden and total loss of climate control occurred during extreme weather conditions. This caused an immediate and rapid rise in cabin temperature to unsafe levels, posing a severe risk of heat exhaustion, dehydration, and heatstroke, particularly for vulnerable passengers. Furthermore, the loss of the A/C system compromised the vehicle's ability to clear window fogging and condensation, rapidly reducing visibility and creating an immediate crash hazard. ​Diagnosis & Inspection Status: The issue has been reproduced and officially confirmed by an authorized dealer/independent service center. However, the vehicle and the failed components have not yet been inspected by the manufacturer, police, or insurance representatives. ​Prior Symptoms & Warning Signs: There were no warning lamps, error messages, or diagnostic trouble codes displayed on the dashboard prior to the failure. UNKNOWN exactly when the internal component degradation began, but the total failure occurred suddenly without prior symptoms."

Component: STRUCTURE

"I was driving on the freeway at a high rate of speed (65-70mph) and a piece of my roof rack broke off my car and flew off into the road. This could have hit a car behind us or harmed a person inside the car. Nothing hit my car to cause it to come off. I showed it to the dealer and they claimed that pieces of cars don't just fall off for no reason. They said they would file a claim for it to be covered under warranty. There was no warning prior to this happening."

Component: STRUCTURE

"I was driving on the freeway at a high rate of speed (65-70mph) and a piece of my roof rack broke off my car and flew off into the road. This could have hit a car behind us or harmed a person inside the car. Nothing hit my car to cause it to come off. I showed it to the dealer and they claimed that pieces of cars don't just fall off for no reason. They said they would file a claim for it to be covered under warranty. There was no warning prior to this happening."

Component: ENGINE

"On May 16, 2026, my 2023 Ford Expedition with 6,197 miles caught fire while I was driving home from work. I smelled smoke inside the cabin, and within moments smoke began coming through the air vents. I pulled over and exited the vehicle. When I got out, I saw the engine compartment was on fire and heavy smoke was coming from under the hood. As I moved away from the vehicle, there were multiple loud pops and bangs coming from the engine area. Police and fire crews responded and extinguished the fire, but the vehicle is a total loss. This was a nearly new vehicle with very low mileage. I believe this was caused by a manufacturing defect. Ford previously settled a class‑action lawsuit involving 2021 Expeditions with engine fire issues, which suggests this problem has not been fully resolved. I am reporting this incident because it is a serious safety hazard and could have resulted in injury or death."

Component: ENGINE

"On May 16, 2026, my 2023 Ford Expedition with 6,197 miles caught fire while I was driving home from work. I smelled smoke inside the cabin, and within moments smoke began coming through the air vents. I pulled over and exited the vehicle. When I got out, I saw the engine compartment was on fire and heavy smoke was coming from under the hood. As I moved away from the vehicle, there were multiple loud pops and bangs coming from the engine area. Police and fire crews responded and extinguished the fire, but the vehicle is a total loss. This was a nearly new vehicle with very low mileage. I believe this was caused by a manufacturing defect. Ford previously settled a class‑action lawsuit involving 2021 Expeditions with engine fire issues, which suggests this problem has not been fully resolved. I am reporting this incident because it is a serious safety hazard and could have resulted in injury or death."

Component: SERVICE BRAKES

"While driving the ABS system failure warning along with 2 other system warnings come on and brakes fall to the floor. My Ford expedition is experiencing the same catastrophic electronic brake booster failure as recall 25S77. The dealer updated the software and the problem continued. Its back at the dealership after happening an additional 4 time and I'm being told it $2500 to replace the electronic brake booster. My VIN is not on the recall but in experiencing the exact life-threatening system failure."

Component: SERVICE BRAKES

"While driving the ABS system failure warning along with 2 other system warnings come on and brakes fall to the floor. My Ford expedition is experiencing the same catastrophic electronic brake booster failure as recall 25S77. The dealer updated the software and the problem continued. Its back at the dealership after happening an additional 4 time and I'm being told it $2500 to replace the electronic brake booster. My VIN is not on the recall but in experiencing the exact life-threatening system failure."

Component: UNKNOWN OR OTHER

"The chrome in the middle console of my vehicle was peeling and cut my finger"

Component: UNKNOWN OR OTHER

"The chrome in the middle console of my vehicle was peeling and cut my finger"

Component: UNKNOWN OR OTHER

"The Panoramic Sunroof spontaneous combusted traveling 75 mph on the interstate. No debris, other vehicles, or overpasses in sight. The explosion and raining glass poses a safety concern. The vehicle is currently in the shop being inspected by the manufacturer, repair shop, insurance adjusters trying to decide who is going to cover the random exploding panoramic sunroof. If government environmental can require auto start stops be put on all consumer vehicles, it seems that the regulatory safety could do something about the overhead exploding glass that is both dangerous and costly."

Component: UNKNOWN OR OTHER

"The Panoramic Sunroof spontaneous combusted traveling 75 mph on the interstate. No debris, other vehicles, or overpasses in sight. The explosion and raining glass poses a safety concern. The vehicle is currently in the shop being inspected by the manufacturer, repair shop, insurance adjusters trying to decide who is going to cover the random exploding panoramic sunroof. If government environmental can require auto start stops be put on all consumer vehicles, it seems that the regulatory safety could do something about the overhead exploding glass that is both dangerous and costly."

Component: UNKNOWN OR OTHER

"Moonroof glass shattered while driving on interstate"

Component: UNKNOWN OR OTHER

"Moonroof glass shattered while driving on interstate"

Component: ELECTRICAL SYSTEM

"The instrument panel went black while driving. Unable to see MPH, Gas, Gauges, or safety alerts, warning lamps, etc. The dealership confirmed there is no recall. This is a safety issue and should not be at the expense of the consumer."

Component: ELECTRICAL SYSTEM

"The instrument panel went black while driving. Unable to see MPH, Gas, Gauges, or safety alerts, warning lamps, etc. The dealership confirmed there is no recall. This is a safety issue and should not be at the expense of the consumer."

Component: STRUCTURE

"The contact owns a 2023 Ford Expedition. The contact stated that upon opening the front driver's side door, the contact became aware that the door hinges were fractured. The failure also occurred on the lower part of the front passenger's side door. The dealer was contacted, and the contact sent a picture of the failure to the dealer. The vehicle was not yet diagnosed or repaired. The manufacturer was not contacted. The failure mileage was 62,305."

Component: STRUCTURE

"The contact owns a 2023 Ford Expedition. The contact stated that upon opening the front driver's side door, the contact became aware that the door hinges were fractured. The failure also occurred on the lower part of the front passenger's side door. The dealer was contacted, and the contact sent a picture of the failure to the dealer. The vehicle was not yet diagnosed or repaired. The manufacturer was not contacted. The failure mileage was 62,305."

Component: SERVICE BRAKES

"Vehicle: 2023 Ford Expedition XLT Max Component: Service Brakes / Hydraulic / Brake Pedal Description of the Problem: The vehicle experiences intermittent brake slippage that occurs randomly approximately 2–3 times per month. The issue happens while decelerating between 10–20 mph. When applying the brakes to slow down, the brake pedal suddenly travels further downward, as if the brakes slip or momentarily lose pressure. This significantly reduces braking confidence and control. The condition occurs without warning and is not driver-induced. When it happens, it feels as though the brakes may fail entirely. Safety Risk: This is a serious safety concern. This vehicle is our primary family vehicle and is regularly used to transport two toddlers and an infant. When the brake slippage occurs, it is frightening and creates fear that the brakes could fail while driving, potentially causing a serious accident. I do not feel the vehicle is safe to operate under these conditions. Service History / Attempts to Repair: •The vehicle is just over one year old and covered under an extended warranty. •The vehicle has been taken to two separate Ford dealerships for diagnosis. •Both dealerships stated they cannot perform repairs unless the issue happens while a technician is driving the vehicle. •I was told I must “wait until the problem gets worse” before any repair can be made. •One dealership kept the vehicle for over one week, drove it 100+ miles, and had three technicians drive it, yet reported they could not replicate the issue. Given how frequently this occurs during normal driving, it is concerning that no corrective action has been taken despite repeated complaints. Outcome / Concern: I am concerned that I am being forced to continue driving a vehicle with a known braking issue until a failure becomes severe enough to be witnessed, placing my family and others at risk. I am submitting this complaint to formally document the issue before serious accident occurs"

Component: SERVICE BRAKES

"Vehicle: 2023 Ford Expedition XLT Max Component: Service Brakes / Hydraulic / Brake Pedal Description of the Problem: The vehicle experiences intermittent brake slippage that occurs randomly approximately 2–3 times per month. The issue happens while decelerating between 10–20 mph. When applying the brakes to slow down, the brake pedal suddenly travels further downward, as if the brakes slip or momentarily lose pressure. This significantly reduces braking confidence and control. The condition occurs without warning and is not driver-induced. When it happens, it feels as though the brakes may fail entirely. Safety Risk: This is a serious safety concern. This vehicle is our primary family vehicle and is regularly used to transport two toddlers and an infant. When the brake slippage occurs, it is frightening and creates fear that the brakes could fail while driving, potentially causing a serious accident. I do not feel the vehicle is safe to operate under these conditions. Service History / Attempts to Repair: •The vehicle is just over one year old and covered under an extended warranty. •The vehicle has been taken to two separate Ford dealerships for diagnosis. •Both dealerships stated they cannot perform repairs unless the issue happens while a technician is driving the vehicle. •I was told I must “wait until the problem gets worse” before any repair can be made. •One dealership kept the vehicle for over one week, drove it 100+ miles, and had three technicians drive it, yet reported they could not replicate the issue. Given how frequently this occurs during normal driving, it is concerning that no corrective action has been taken despite repeated complaints. Outcome / Concern: I am concerned that I am being forced to continue driving a vehicle with a known braking issue until a failure becomes severe enough to be witnessed, placing my family and others at risk. I am submitting this complaint to formally document the issue before serious accident occurs"

Component: ELECTRICAL SYSTEM,SERVICE BRAKES,FORWARD COLLISION AVOIDANCE

"While pulling out of a parking lot onto a 4 lane undivided city street, the vehicle flashed a warning light on the dash saying “Trailer Brakes Engaged” and the vehicle came to an abrupt stop in the lanes of active traffic narrowly avoiding a collision. As if the parking brake had set uncommanded. The vehicle was not and has never pulled a trailer since we’ve owned it the last 9 months. The engine was stalled but accessory was still on. After an off/on cycle the vehicle started and went into gear functioning normally. Immediately taken to a ford/Lincoln dealer. They inspected and told us they found no codes and no discernible issues with the vehicle and it was released. Will be dropped off at another ford shop in the morning to continue diagnosis."

Component: ELECTRICAL SYSTEM,SERVICE BRAKES,FORWARD COLLISION AVOIDANCE

"While pulling out of a parking lot onto a 4 lane undivided city street, the vehicle flashed a warning light on the dash saying “Trailer Brakes Engaged” and the vehicle came to an abrupt stop in the lanes of active traffic narrowly avoiding a collision. As if the parking brake had set uncommanded. The vehicle was not and has never pulled a trailer since we’ve owned it the last 9 months. The engine was stalled but accessory was still on. After an off/on cycle the vehicle started and went into gear functioning normally. Immediately taken to a ford/Lincoln dealer. They inspected and told us they found no codes and no discernible issues with the vehicle and it was released. Will be dropped off at another ford shop in the morning to continue diagnosis."

Component: VEHICLE SPEED CONTROL

"The contact owned a 2023 Ford Expedition. The contact stated that while his wife was occupying the vehicle at the residence and attempting to park in the drive postion, the vehicle independently accelerated and crashed into the garage wall, causing damage to the garage wall, refrigerator, and storage cabinet. The brake pedal was depressed, but the vehicle was in full throttle and failed to stop. No warning light was illuminated. During the failure, the contact's wife was the only occupant inside the vehicle. In addition, the display screen went blank. The contact's wife had not sustained an injury, and no medical attention was needed. No police report was filed. The vehicle was not taken to the dealer to be diagnosed. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 38,000."

Component: VEHICLE SPEED CONTROL

"The contact owned a 2023 Ford Expedition. The contact stated that while his wife was occupying the vehicle at the residence and attempting to park in the drive postion, the vehicle independently accelerated and crashed into the garage wall, causing damage to the garage wall, refrigerator, and storage cabinet. The brake pedal was depressed, but the vehicle was in full throttle and failed to stop. No warning light was illuminated. During the failure, the contact's wife was the only occupant inside the vehicle. In addition, the display screen went blank. The contact's wife had not sustained an injury, and no medical attention was needed. No police report was filed. The vehicle was not taken to the dealer to be diagnosed. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 38,000."

Component: SEAT BELTS

"The seatbelt strap malfunctioned ( locked) and and I was unable to loosen the straps .. resulting in having to cut the strap to get my child out"

Component: SEAT BELTS

"The seatbelt strap malfunctioned ( locked) and and I was unable to loosen the straps .. resulting in having to cut the strap to get my child out"

Component: ELECTRICAL SYSTEM

"HOOD COWLING COMING BREAKING SEAL CAUSING BATTERY JUNCTION BOX TO GET WATER IN AND SHORT-OUT JUCTION BOX AND NOT ALLOWING THE CAR NOT TO START."

Component: ELECTRICAL SYSTEM

"HOOD COWLING COMING BREAKING SEAL CAUSING BATTERY JUNCTION BOX TO GET WATER IN AND SHORT-OUT JUCTION BOX AND NOT ALLOWING THE CAR NOT TO START."

Component: ENGINE,FUEL/PROPULSION SYSTEM

"It made a loud boom I stopped thought it was a tire when I got out of the car flames started to come out of the driver side wheel well"

Component: ELECTRICAL SYSTEM

"The contact owns a 2023 Ford Expedition. The contact stated that while the vehicle was parked and occupied, or while the vehicle was being driven, the front driver’s side buttons on the door failed to operate as designed. A dealer was contacted. The vehicle was taken to the dealer to be diagnosed, and the contact was informed that the wiring loom needed to be replaced and re-routed. The vehicle was repaired. The manufacturer was notified of the failure but offered no assistance. The approximate failure mileage was 46,000."

Component: SERVICE BRAKES

"While driving at varying speeds the service brake warning light would come on and the vehicle would shudder while decelerating before coming to a full stop as the brakes were engaged resulting in a longer distance required for breaking. After initial occurrence the vehicle was inspected by the local dealership where they determined that "The brake lines passed inspection and there were no other observable issues." This happened roughly 20 times over a collective 2 hours of drive time throughout a 3 week period. Eventually the vehicle's computer system disabled the ABS and provided an error code regarding a faulty ABS. Upon a second inspection by the local dealership service department accompanied by video footage that I took of the incident the following report was made by the service department "Brake Booster Replacement - C0047:31 - Internal EBB failure""

Component: AIR BAGS

"My "restraints indicator lamp warning" is going off occasionally. Ford just contacted me to tell me that my airbag will not deploy if needed."

Component: POWER TRAIN,ELECTRICAL SYSTEM

"See attached document for complaint."

Component: POWER TRAIN,ELECTRICAL SYSTEM

"See attached document for complaint."

Component: SERVICE BRAKES

"I have taken my vehicle Ford Country in Henderson NV for this recall. I took my expedition in on June 6. As of today there has been zero work done on this recall. I am repeatedly told that there is nothing that can be done until Ford releases the permanent fix. I have a rental and the service agent at this dealership has been great. I have seen the conversation between him and the recall department at Ford and they are refusing to fix it temporarily. This is completely unacceptable. Ford either needs to provide a temporary fix or release the permanent fix so that I can get my vehicle back."

Component: UNKNOWN OR OTHER

"I was driving down road about to get on [xxx] in Tucson,Az when we heard a loud boom inside my car. We pulled over to see what happen. My moon room had exploded for no reason and nothing hitting it. You could clearly see the force came from inside vs outside due to an object. As we drove down the road to take it to ford glass proceeded to fall down. We are very lucky in the only one that got a piece of glasses in my hand and not on my infant. My sunroof component has had 2 issues prior to this and I feel the glass was faulty and my car has a mal-alignment. Ford is denying any responsibility. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)"

Component: ELECTRICAL SYSTEM,VISIBILITY

"The contact owns a 2023 Ford Expedition. The contact stated that while operating the vehicle, the front driver’s and passenger’s side electric mirrors could not be adjusted from the front driver’s door main switch. Additionally, the windows failed to roll up and to roll down while using the front driver’s door main switch. The contact stated that while in a parking garage, the front driver’s side window failed to roll down, and the driver was unable to immediately insert the parking garage ticket to exit the garage. The contact stated that the failure was intermittent. The vehicle was taken to the local dealer who replaced the front driver’s door main switch module, but the failure later reoccurred. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 21,000."

Component: ELECTRICAL SYSTEM,VISIBILITY

"The contact owns a 2023 Ford Expedition. The contact stated that while operating the vehicle, the front driver’s and passenger’s side electric mirrors could not be adjusted from the front driver’s door main switch. Additionally, the windows failed to roll up and to roll down while using the front driver’s door main switch. The contact stated that while in a parking garage, the front driver’s side window failed to roll down, and the driver was unable to immediately insert the parking garage ticket to exit the garage. The contact stated that the failure was intermittent. The vehicle was taken to the local dealer who replaced the front driver’s door main switch module, but the failure later reoccurred. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 21,000."

Component: ELECTRICAL SYSTEM

"The contact owns a 2023 Ford Expedition. The contact stated that while the vehicle was parked and turned off, the contact received a "Low Battery" notification from the vehicle's mobile app. The contact stated that upon attempting to start the vehicle, the vehicle failed to start. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA hotline for further assistance. The failure mileage was approximately 48,000."

Component: ELECTRICAL SYSTEM

"The vehicle was sitting at idle in the driveway when a loud boom was heard followed by loud crackling noises coming from what sounded like, everywhere. I turned off the radio and the noise continues. I turned off the vehicle and exited and the noise continued for about one minute before stopping. It has not happened again and I will take it to the dealership to get checked. Had this happened while driving at highway speeds it could have caused a reaction resulting in a horrific crash."

Component: UNKNOWN OR OTHER

"Just bought this 2023 Ford Expedition it was used, within 1 hour of owning it, the Sunroof just shattered and pieces of glass came falling down in-between my kids. Didn't seem like anything hit the sunroof, it just shattered on it's own! took back to dealership, they don't want to take blame and told us it has to go thru our insurance! they would cover the deductible. After looking into other stories, seems like ford has fault glass installed, i read other saying the same, that their windows have just exploded and the glass just shattering without anything hitting them! Feel like this is a safety concern and ford isn't helping with! think the glass hit daughter in face giving little scratch, nothing to major luckly!"

Component: VISIBILITY

"The contact owns a 2023 Ford Expedition. The contact stated while driving 75 MPH and taking an exit, the panoramic sunroof exploded without impact. The sunroof exploded from the inside going outward. The contact stated that the first panoramic slide had exploded, and the second sunroof was still intact. There was glass on the interior of the vehicle. There were no warning lights illuminated. There were no reported injuries. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The approximate failure mileage was 55,384."

Component: UNKNOWN OR OTHER

"Extremely loud/deafening loud pop and static noise coming from the speakers. Scared me so bad while I was driving had to throw the hazard on and stop the vehicle in road. The volume would not adjust and radio would not turn off. Had to turn off the vehicle and open the door for the loud static turn off. At restart deafening static immediately came back. Ears were ringing and felt numb in the inside. No recalls found for this and feel this is extremely dangerous while driving. Had vehicle serviced at dealer and no mention it offer to update the known issue"

Component: FORWARD COLLISION AVOIDANCE,LANE DEPARTURE

"The vehicle experienced a failure of multiple driver assistance and safety systems, with warning messages displayed in the instrument panel cluster. The affected systems include Adaptive Cruise Control, Automatic Emergency Braking, Blind Spot Warning, Forward Collision Warning, Lane Departure Warning, Lane Keeping Assistance, Parking Collision Warning, and Rear Cross Traffic Warning. All of these features are currently inoperative. During normal vehicle operation, messages indicated that driver assistance features were unavailable or malfunctioning. Diagnostic trouble codes related to invalid data and lost communication were stored in multiple modules. The failures appear to be caused by the Image Processing Module A (IPMA) intermittently not communicating on the vehicle network. This condition created a significant safety risk because multiple federally advertised and manufacturer-promoted crash-avoidance and collision-mitigation features were unexpectedly disabled during normal driving. The sudden loss of these systems reduces situational awareness and increases the risk of a collision, particularly during highway driving, lane changes, and parking maneuvers. The issue has been acknowledged by the manufacturer in Special Service Message (SSM 53419), which identifies IPMA software as the likely cause. Temporary recovery procedures have been attempted, but the problem continues to recur. A permanent repair has not been provided, despite this condition being known for over one year. The issue has been confirmed by dealer diagnostics. Warning messages appeared prior to and during the loss of functionality. The affected components remain installed and are available for inspection. The underlying software defect has not been permanently corrected as of this report."

Component: FORWARD COLLISION AVOIDANCE,LANE DEPARTURE

"The vehicle experienced a failure of multiple driver assistance and safety systems, with warning messages displayed in the instrument panel cluster. The affected systems include Adaptive Cruise Control, Automatic Emergency Braking, Blind Spot Warning, Forward Collision Warning, Lane Departure Warning, Lane Keeping Assistance, Parking Collision Warning, and Rear Cross Traffic Warning. All of these features are currently inoperative. During normal vehicle operation, messages indicated that driver assistance features were unavailable or malfunctioning. Diagnostic trouble codes related to invalid data and lost communication were stored in multiple modules. The failures appear to be caused by the Image Processing Module A (IPMA) intermittently not communicating on the vehicle network. This condition created a significant safety risk because multiple federally advertised and manufacturer-promoted crash-avoidance and collision-mitigation features were unexpectedly disabled during normal driving. The sudden loss of these systems reduces situational awareness and increases the risk of a collision, particularly during highway driving, lane changes, and parking maneuvers. The issue has been acknowledged by the manufacturer in Special Service Message (SSM 53419), which identifies IPMA software as the likely cause. Temporary recovery procedures have been attempted, but the problem continues to recur. A permanent repair has not been provided, despite this condition being known for over one year. The issue has been confirmed by dealer diagnostics. Warning messages appeared prior to and during the loss of functionality. The affected components remain installed and are available for inspection. The underlying software defect has not been permanently corrected as of this report."