2021 FORD EXPEDITION Safety Overview

Component: STRUCTURE

"Part of the luggage rack broke off of the vehicle while driving down the road. The vehicle had not been previously damaged. The broken piece could not be recovered."

Component: STRUCTURE

"Part of the luggage rack broke off of the vehicle while driving down the road. The vehicle had not been previously damaged. The broken piece could not be recovered."

Component: POWER TRAIN

"COMPONENT: 2021 Ford Expedition Max 10R80 transmission. The CDF clutch cylinder (7H351) sleeve exhibits axial movement, breaking the clutch apply-pressure seal so commanded torque is not transmitted to the wheels. Engine revs while the vehicle fails to accelerate or move forward. Vehicle is available for NHTSA inspection and testing. INCIDENTS (7/5/2026, same drive cycle): (1) Highway, after braking from a 60 mph cruise to a 15-20 mph roll over a few hundred feet, the transmission failed to engage any gear on re-acceleration. (2) City, at 35 mph while accelerating to merge lanes, the transmission again failed to engage a gear. Engine 205-220F, Trans 200-210F, Indicated Gears 4th/5th, Odometer 120,217. Second owner; purchased at 115,067 mi. SAFETY: Sudden, unannounced loss of forward propulsion with no dash warning directly endangers my wife, my children, and other motorists during ordinary driving. Merging: stuck at 40-50 mph in 65-80 mph traffic invites a high-differential rear-end impact. Intersections/left turns: a mid-turn stall exposes the passenger side (where my family sits) to a T-bone at posted speed. Evasive maneuvers: failed acceleration converts a near-miss into an unavoidable collision. Grades: the ~7,000-lb SUV can roll backward or stall in-lane on short-sight-line hills. Towing (rated capacity, used regularly) magnifies every risk to trailer and following traffic. Shoulder stranding invites secondary collisions, a known highway-fatality cause. The defect is unpredictable. I cannot pre-empt merges, intersections, hills, or tows. DEALER/INDEPENDENT CONFIRMATION: None. I have not brought the vehicle in for service, to avoid compromising any NHTSA inspection or testing. MFR/POLICE/INSURANCE INSPECTION: None; no crash has occurred to this date. PRIOR WARNINGS: None. No lamps, messages, or symptoms preceded these failures, which first occurred 7/5/2026. Ford has documented awareness of the 10R80 CDF clutch cylinder defect and has not issued a recall."

Component: POWER TRAIN

"COMPONENT: 2021 Ford Expedition Max 10R80 transmission. The CDF clutch cylinder (7H351) sleeve exhibits axial movement, breaking the clutch apply-pressure seal so commanded torque is not transmitted to the wheels. Engine revs while the vehicle fails to accelerate or move forward. Vehicle is available for NHTSA inspection and testing. INCIDENTS (7/5/2026, same drive cycle): (1) Highway — after braking from a 60 mph cruise to a 15-20 mph roll, the transmission failed to engage any gear on re-acceleration. (2) City — at 35 mph while accelerating to merge lanes, the transmission again failed to engage a gear. Engine 205-220F, Trans 200-210F, Indicated Gears 4th/5th, Odometer 120,217. Second owner; purchased at 115,067 mi. SAFETY: Sudden, unannounced loss of forward propulsion with no dash warning directly endangers my wife, my children, and other motorists during ordinary driving. Merging: stuck at 40-50 mph in 65-80 mph traffic invites a high-differential rear-end impact. Intersections/left turns: a mid-turn stall exposes the passenger side (where my family sits) to a T-bone at posted speed. Evasive maneuvers: failed acceleration converts a near-miss into an unavoidable collision. Grades: the ~7,000-lb SUV can roll backward or stall in-lane on short-sight-line hills. Towing (rated capacity) magnifies every risk to trailer and following traffic. Shoulder stranding invites secondary collisions, a known highway-fatality cause. The defect is unpredictable — I cannot pre-empt merges, intersections, hills, or tows. DEALER/INDEPENDENT CONFIRMATION: None. I have not brought the vehicle in for service, to avoid compromising any NHTSA inspection or testing. MFR/POLICE/INSURANCE INSPECTION: None; no crash has occurred to this date. PRIOR WARNINGS: None. No lamps, messages, or symptoms preceded these failures, which first occurred 7/5/2026. Ford has documented awareness of the 10R80 CDF clutch cylinder design defect and has not issued a recall (TSB 23-2250)."

Component: POWER TRAIN

"COMPONENT: 2021 Ford Expedition Max 10R80 transmission. The CDF clutch cylinder (7H351) sleeve exhibits axial movement, breaking the clutch apply-pressure seal so commanded torque is not transmitted to the wheels. Engine revs while the vehicle fails to accelerate or move forward. Vehicle is available for NHTSA inspection and testing. INCIDENTS (7/5/2026, same drive cycle): (1) Highway, after braking from a 60 mph cruise to a 15-20 mph roll over a few hundred feet, the transmission failed to engage any gear on re-acceleration. (2) City, at 35 mph while accelerating to merge lanes, the transmission again failed to engage a gear. Engine 205-220F, Trans 200-210F, Indicated Gears 4th/5th, Odometer 120,217. Second owner; purchased at 115,067 mi. SAFETY: Sudden, unannounced loss of forward propulsion with no dash warning directly endangers my wife, my children, and other motorists during ordinary driving. Merging: stuck at 40-50 mph in 65-80 mph traffic invites a high-differential rear-end impact. Intersections/left turns: a mid-turn stall exposes the passenger side (where my family sits) to a T-bone at posted speed. Evasive maneuvers: failed acceleration converts a near-miss into an unavoidable collision. Grades: the ~7,000-lb SUV can roll backward or stall in-lane on short-sight-line hills. Towing (rated capacity, used regularly) magnifies every risk to trailer and following traffic. Shoulder stranding invites secondary collisions, a known highway-fatality cause. The defect is unpredictable. I cannot pre-empt merges, intersections, hills, or tows. DEALER/INDEPENDENT CONFIRMATION: None. I have not brought the vehicle in for service, to avoid compromising any NHTSA inspection or testing. MFR/POLICE/INSURANCE INSPECTION: None; no crash has occurred to this date. PRIOR WARNINGS: None. No lamps, messages, or symptoms preceded these failures, which first occurred 7/5/2026. Ford has documented awareness of the 10R80 CDF clutch cylinder defect and has not issued a recall."

Component: POWER TRAIN

"COMPONENT: 2021 Ford Expedition Max 10R80 transmission. The CDF clutch cylinder (7H351) sleeve exhibits axial movement, breaking the clutch apply-pressure seal so commanded torque is not transmitted to the wheels. Engine revs while the vehicle fails to accelerate or move forward. Vehicle is available for NHTSA inspection and testing. INCIDENTS (7/5/2026, same drive cycle): (1) Highway — after braking from a 60 mph cruise to a 15-20 mph roll, the transmission failed to engage any gear on re-acceleration. (2) City — at 35 mph while accelerating to merge lanes, the transmission again failed to engage a gear. Engine 205-220F, Trans 200-210F, Indicated Gears 4th/5th, Odometer 120,217. Second owner; purchased at 115,067 mi. SAFETY: Sudden, unannounced loss of forward propulsion with no dash warning directly endangers my wife, my children, and other motorists during ordinary driving. Merging: stuck at 40-50 mph in 65-80 mph traffic invites a high-differential rear-end impact. Intersections/left turns: a mid-turn stall exposes the passenger side (where my family sits) to a T-bone at posted speed. Evasive maneuvers: failed acceleration converts a near-miss into an unavoidable collision. Grades: the ~7,000-lb SUV can roll backward or stall in-lane on short-sight-line hills. Towing (rated capacity) magnifies every risk to trailer and following traffic. Shoulder stranding invites secondary collisions, a known highway-fatality cause. The defect is unpredictable — I cannot pre-empt merges, intersections, hills, or tows. DEALER/INDEPENDENT CONFIRMATION: None. I have not brought the vehicle in for service, to avoid compromising any NHTSA inspection or testing. MFR/POLICE/INSURANCE INSPECTION: None; no crash has occurred to this date. PRIOR WARNINGS: None. No lamps, messages, or symptoms preceded these failures, which first occurred 7/5/2026. Ford has documented awareness of the 10R80 CDF clutch cylinder design defect and has not issued a recall (TSB 23-2250)."

Component: VISIBILITY/WIPER

"Turn.wipers on were slow to move, then just quit, now they don't move at all,all with no warning"

Component: VISIBILITY/WIPER

"Turn.wipers on were slow to move, then just quit, now they don't move at all,all with no warning"

Component: SERVICE BRAKES

"I am filing this complaint because my vehicle is exhibiting the exact failure mode detailed in Ford Recall 26S48 (NHTSA Campaign 26V402000), but my VIN is currently excluded from the recall population." A loud, heavy metal-on-metal "CLUNK" or "THUNK" right under the center console or floorboards the exact second I change gears. It feels like the transmission is violently dropping or snapping into gear. I even feel a physical jar or shudder through the shift dial and I brake pedal."

Component: SERVICE BRAKES

"I am filing this complaint because my vehicle is exhibiting the exact failure mode detailed in Ford Recall 26S48 (NHTSA Campaign 26V402000), but my VIN is currently excluded from the recall population." A loud, heavy metal-on-metal "CLUNK" or "THUNK" right under the center console or floorboards the exact second I change gears. It feels like the transmission is violently dropping or snapping into gear. I even feel a physical jar or shudder through the shift dial and I brake pedal."

Component: POWER TRAIN

"While driving down the highway at 70 miles an hour, the transmission popped out of gear the engine revved, and when the transmission went back into gear, it engaged into second gear and locked up the rear tires on the highway. I believe this is due to the CDF drum bushing, causing Line pressure problems. But this has almost caused me in my family to get into an accident."

Component: POWER TRAIN

"While driving down the highway at 70 miles an hour, the transmission popped out of gear the engine revved, and when the transmission went back into gear, it engaged into second gear and locked up the rear tires on the highway. I believe this is due to the CDF drum bushing, causing Line pressure problems. But this has almost caused me in my family to get into an accident."

Component: POWER TRAIN

"Hard Shifting & Slipping: Drivers frequently report clunking, hard shifts (particularly around gears 3-5), and the vehicle lurching forward when accelerating. It does this while driving and is a serious safety issue.we complained to the dealer about a year ago and they told us they checked and it was fine. Now it is worse."

Component: POWER TRAIN

"Hard Shifting & Slipping: Drivers frequently report clunking, hard shifts (particularly around gears 3-5), and the vehicle lurching forward when accelerating. It does this while driving and is a serious safety issue.we complained to the dealer about a year ago and they told us they checked and it was fine. Now it is worse."

Component: FUEL/PROPULSION SYSTEM

"This vehicle has 70K miles and the fuel pump died, confirmed by Dick Smith Ford in Columbia, SC. There were no warning lights or messages via our Ford app. There were no symptoms prior to failure. The vehicle just died in the middle of the road on a train track with our family in danger. We could have been hit by cars behind us or stuck on the train track with a train approaching. We were in the middle of the road on a train track in Columbia, SC, 2.5hrs away from our home. Our family waited 2.5hrs for the vehicle to be towed and then had to take a $200 Uber from Columbia, SC to Charleston, SC to get home. The quoted cost to repair the vehicle just to get it back home is $2,000. Ford has recalled all the Ford trucks for 2021 that use this same engine. Ford has recalled the 2022 Expedition which is identical to the 2021. Ford has recalled the 2021 Lincoln Navigator that is the same platform as the Expedition only aesthetically upgraded. I believe they didn't recall the 2021 Ford Expedition due the the volume of cars that would be recalled. "

Component: FUEL/PROPULSION SYSTEM

"This vehicle has 70K miles and the fuel pump died, confirmed by Dick Smith Ford in Columbia, SC. There were no warning lights or messages via our Ford app. There were no symptoms prior to failure. The vehicle just died in the middle of the road on a train track with our family in danger. We could have been hit by cars behind us or stuck on the train track with a train approaching. We were in the middle of the road on a train track in Columbia, SC, 2.5hrs away from our home. Our family waited 2.5hrs for the vehicle to be towed and then had to take a $200 Uber from Columbia, SC to Charleston, SC to get home. The quoted cost to repair the vehicle just to get it back home is $2,000. Ford has recalled all the Ford trucks for 2021 that use this same engine. Ford has recalled the 2022 Expedition which is identical to the 2021. Ford has recalled the 2021 Lincoln Navigator that is the same platform as the Expedition only aesthetically upgraded. I believe they didn't recall the 2021 Ford Expedition due the the volume of cars that would be recalled. "

Component: UNKNOWN OR OTHER

"Manufacturer Recall Number 26S38 NHTSA Recall Number26V368 My husband and I have both cut our hands on the ripped chrome trim inside of our Expedition Max. We ripped part of the piece off, but there’s a sharp exposed edge and it poses a huge risk. The dealership said the only remedy is buying a new center console and that was quoted to us at nearly $1000."

Component: UNKNOWN OR OTHER

"Manufacturer Recall Number 26S38 NHTSA Recall Number26V368 My husband and I have both cut our hands on the ripped chrome trim inside of our Expedition Max. We ripped part of the piece off, but there’s a sharp exposed edge and it poses a huge risk. The dealership said the only remedy is buying a new center console and that was quoted to us at nearly $1000."

Component: SEAT BELTS,STRUCTURE

"The contact owns a 2021 Ford Expedition. The contact received notifications of NHTSA Campaign Numbers: 26V344000 (Seat Belts) and 26V368000 (Structure); however, the parts to do the recall repairs were not yet available. The local dealer was not made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure."

Component: SEAT BELTS,STRUCTURE

"The contact owns a 2021 Ford Expedition. The contact received notifications of NHTSA Campaign Numbers: 26V344000 (Seat Belts) and 26V368000 (Structure); however, the parts to do the recall repairs were not yet available. The local dealer was not made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure."

Component: POWER TRAIN

"Bad parts in the transmission the cdf drum part is not good. While on the highway I was driving and my car lost all power and for about 5-6 seconds lost all power to the car until the transmission kicked into gear. I have has it in for a warranty and they keep saying it nothing then final it went back in and they tell me it the cdf drum in the transmission but this is not a safety concern. It is to me I have 2 kids and if something happens and causes a accident and something happens to my daughter who is replacing my kids no one and Ford will wipe there hands from it. A mandatory recall needs to happen on these transmission and get them fix properly. They did a recall for a piece of trim that cuts when it is lose but they can't do it on this. Unbelievable"

Component: POWER TRAIN

"Bad parts in the transmission the cdf drum part is not good. While on the highway I was driving and my car lost all power and for about 5-6 seconds lost all power to the car until the transmission kicked into gear. I have has it in for a warranty and they keep saying it nothing then final it went back in and they tell me it the cdf drum in the transmission but this is not a safety concern. It is to me I have 2 kids and if something happens and causes a accident and something happens to my daughter who is replacing my kids no one and Ford will wipe there hands from it. A mandatory recall needs to happen on these transmission and get them fix properly. They did a recall for a piece of trim that cuts when it is lose but they can't do it on this. Unbelievable"

Component: STRUCTURE

"The contact owns a 2021 Ford Expedition. The contact stated that while reaching into the center console of the vehicle, a sharp edge on the trim caused an injury to the thumb. The contact stated that the issue reoccurred, and the sharp edge caused a cut on the thumb. No medical attention was needed; however, bandages were used on the cuts. Neither the dealer nor the manufacturer was notified of the issue. The contact associated the issue with NHTSA Campaign Number: 26V368000 (Structure). The approximate failure mileage was 73,000."

Component: STRUCTURE

"The contact owns a 2021 Ford Expedition. The contact stated that while reaching into the center console of the vehicle, a sharp edge on the trim caused an injury to the thumb. The contact stated that the issue reoccurred, and the sharp edge caused a cut on the thumb. No medical attention was needed; however, bandages were used on the cuts. Neither the dealer nor the manufacturer was notified of the issue. The contact associated the issue with NHTSA Campaign Number: 26V368000 (Structure). The approximate failure mileage was 73,000."

Component: POWER TRAIN

"“10R80 transmission slips and loses power during acceleration. Matches Ford TSB 23‑2250. Sudden loss of propulsion creates safety risk when merging or crossing intersections.”"

Component: POWER TRAIN

"“10R80 transmission slips and loses power during acceleration. Matches Ford TSB 23‑2250. Sudden loss of propulsion creates safety risk when merging or crossing intersections.”"

Component: VISIBILITY/WIPER

"On two separate occasions while driving on the interstate in the rain, the wipers stopped working. Two of the times they stopped in the up position and once they stopped in the middle of the stroke and it was hard to see. After turning the wiper switch to different settings, the wipers started working again."

Component: VISIBILITY/WIPER

"On two separate occasions while driving on the interstate in the rain, the wipers stopped working. Two of the times they stopped in the up position and once they stopped in the middle of the stroke and it was hard to see. After turning the wiper switch to different settings, the wipers started working again."

Component: POWER TRAIN

"I have had issues with the 10 speed transmission on my Expedition. I looked up my year model and type of transmission and there is a NHTSA recall on select model year transmissions within my year range. My vehicle is doing the same thing that is stated in the recall. I spoke to a transmission shop and they are the ones that informed me of the transmission issues and recalls. I reached out to my local Ford dealership and they looked up my vehicle and informed me that my vehicle was not affected. I said it seemed to be doing the exact same thing listed. He said if its not on the list, we won't cover the repair. What needs to happen to have my transmission repaired under the recall?"

Component: POWER TRAIN

"Was traveling on the roadway when my vehicle suddenly lost its ability to change gears. I had to put the transmission into manual mode to be able to pull to the side of the roadway and stop. The vehicle was towed to the repair facility where I was informed the transmission needed to be replaced. I was almost struck from behind by a motorist due to not being able to continue forward. I was informed this is a common defect in the transmission and the cost to replace the transmission is approximately $9000. Due to the low mileage on the vehicle, this is unacceptable and a safety risk."

Component: UNKNOWN OR OTHER

"Mid shift between 5th and 6th gear it sounded like marbles in my engine(grinding) so I let off the gas. It then switched down to 1st gear shuttered and slowed down and then shifted back to 6th. Was lucky no one was behind me or I would have been rear ended. Then going up my driveway same day. It disengaged(stopped) part way up my driveway. Wouldn’t go into gear and wouldn’t move. I had to shut it off put it in park and start it again. Then when I shifted back to drive it made some clunking noises and didn’t move until I put it in reverse. I rolled down the hill then was able to shift into drive and go up the driveway. I no longer trust it. So it’s been parked ever since."

Component: ELECTRICAL SYSTEM,ENGINE

"I took my vehicle to the dealership to have all recall work done on Feb. 11th 2026. I was told i am up to date on all my recall work at that time. When I received my vehicle back It would intermittently just shut down for no apparent reason while sitting at stop lights, or just stopped in that fashion. I called and the dealership they said unless they could recreate the issue somewhat easily there was noting they could really do. So while parked in driveway the vehicle again had no power, I used my emergency key to get into vehicle and opened the hood to which I found the battery terminal connections were never tighten. I could take them off by hand. This told me the mechanic at the dealership didn't complete job and tighten my battery connections, Fast forward to April 18th, it was raining, I parked vehicle, still running, went into post office ( I was only gone for 30 seconds)and I came out to white smoke billowing out from under the hood. I opened hood the large flames shooting up. I quickly grabbed a fire extinguisher I had in the car and put 90% of the fire out, it was still burning at the fuse junction box, moments later a police officer showed up with fire extinguisher and was able to put it out. The car would not stop running, so once the fire dept. arrived they had to cut the battery terminals to shut the vehicle down. This was also the first time I drove vehicle in the rain since my recall work was done. The fire dept. and I realized the fuse box cover was not in place. So now this same mechanic that did't tighten battery terminals was also neglectful in not replacing the fuse box cover. I believe this neglect partially if not wholly caused this fire. It is highly probable that water got into the fuse box and shortened everything out which caused the fire. I have a document from the dealership that states they did the recall work for 22S36 - Underhood fires. But this website says this work was not performed. No inspection from anyone has been done"

Component: POWER TRAIN,ENGINE

"The contact owns a 2021 Ford Expedition. The contact stated that while driving at an undisclosed speed, the transmission unexpectedly downshifted and the vehicle jerked abnormally. The contact stated that there was an abnormal sound coming from the vehicle with the Check Engine warning light illuminated. The failure was persistent. The vehicle was taken to the dealer where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The contact referenced an unknown recall; however, the VIN was not associated with a recall related to the failure. The manufacturer was made aware of the failure but provided no assistance. The contact was informed that the repair was not covered under recall. The failure mileage was approximately 62,500."

Component: POWER TRAIN,ENGINE

"The contact owns a 2021 Ford Expedition. The contact stated that while driving at an undisclosed speed, the transmission unexpectedly downshifted and the vehicle jerked abnormally. The contact stated that there was an abnormal sound coming from the vehicle with the Check Engine warning light illuminated. The failure was persistent. The vehicle was taken to the dealer where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The contact referenced an unknown recall; however, the VIN was not associated with a recall related to the failure. The manufacturer was made aware of the failure but provided no assistance. The contact was informed that the repair was not covered under recall. The failure mileage was approximately 62,500."

Component: ENGINE

"When my transmission is shifting, it almost stalls about 3-4 times everytime you start off. It is a hard shift that makes it fee like the car suddenly stops then goes back. I have had it happen 3 times that I thought my car died after stopping, making weird noises, then took off like normal. I am waiting for my car to just die as I am driving. The Ford dealership said I need a new transmission. The recall is out there for other vehicles like mine, yet mine is not listed. When you read what Ford says will happen- EXACTLY what my car does!!!!! My 2021 Ford Expedition Max has 70,000 miles on it now, but when it started had about 67,000"

Component: ENGINE

"When my transmission is shifting, it almost stalls about 3-4 times everytime you start off. It is a hard shift that makes it fee like the car suddenly stops then goes back. I have had it happen 3 times that I thought my car died after stopping, making weird noises, then took off like normal. I am waiting for my car to just die as I am driving. The Ford dealership said I need a new transmission. The recall is out there for other vehicles like mine, yet mine is not listed. When you read what Ford says will happen- EXACTLY what my car does!!!!! My 2021 Ford Expedition Max has 70,000 miles on it now, but when it started had about 67,000"

Component: UNKNOWN OR OTHER

"The vehicle has jerky and harsh shifting. Almost got into an accident when car would not accelerate on the freeway. Appears this is a known issue with my vehicle. Took it in to be checked and initially they didn’t find anything. Problem persisted so I told them to test drive it for a bit and they said it was the CDF Drum and C clutch circuit which is apparently tied to the transmission issue. I called Ford about coverage due to the recall but they said the recall that is out there for this issue is not yet available for my specific car. This is dangerous and can cause serious accidents. Would like to know what it will take for Ford to include my vehicle in the recall. Would like Ford to take responsibility and pay for fixing this issue."

Component: POWER TRAIN

"Transmission harsh shifting. Common problem with ford on the 10r80. Was told from ford need new transmission"

Component: POWER TRAIN

"The 10r80 transmission went out in it after 80k miles. It would get "stuck" in gears and not want to shift. The lack of shifting would cause the vehicle to stall while driving. Ford was able to reproduce the issue and the transmission is getting replaced by Ford through our extended warranty company. There was a clunking noise when driving prior to the transmission having shifting issues. No, there were not any warning lights when this was happening."

Component: UNKNOWN OR OTHER

"In cold weather the doors will become unlatched and open. This has happened to all 4 doors, driver side, passenger side, rear driver and rear passenger. We will be driving and the doors will randomly become unlatched and fly open. We have small children and they could have been killed due to this incident. It is extremely unsafe and problematic. We are unbelievably fortunate that our children have not been killed due to these incidents. It can happen at any moment and the doors will not close for several hours or days once they become unlatched. Typically when the weather warms up they will close again, which can take days. We have had friends/family allow us to use their garage to park the car so the car will warm up and we can re-close the doors, only to have them fly open again at some random time. This is a very dangerous defect that poses a significant health and safety, especially to children and babies. Additionally it is a liability as it can take several hours/days before the latches will close again. This requires the use of ratchet straps to hold the doors closed as the latches will not close (even if you attempt to reset the latches manually). However, having ratchet straps running from door handle to door handle to keep the doors closed poses other safety concerns. When I reached out to the ford mechanic I was told to replace the door latches as they may be defective. I had the driver side door latch replaced, but unfortunately the problem persists (about twice in the two months since it was replaced)."

Component: POWER TRAIN

"When attempting to pass or slowing and then pressing the gas regain speed, transmission disengages, engines revs, transmission down shifts to 1st gear and then attempting to "find" the correct gear. This has happened multiple times and a few of those times has left us susceptible to being struck by another vehicle due to no engine power to the power train to move the vehicle."

Component: FUEL/PROPULSION SYSTEM

"Down to 3 gallons gas stopped and added to half a tank. Left vehicle running while filling. Pulled out of gas station and vehicle started to sputter, drove 50 more feet and vehicle died and would not restart. Confirmed unleaded and station had no reports of bad gas. Towed to repair facility where dead fuel pump was diagnosed and replaced. Ford recall 25S75 includes some 2022 expeditions but not this 2021 with only 43,000 miles and no previous issues."

Component: POWER TRAIN

"When attempting to pass or slowing and then pressing the gas regain speed, transmission disengages, engines revs, transmission down shifts to 1st gear and then attempting to "find" the correct gear. This has happened multiple times and a few of those times has left us susceptible to being struck by another vehicle due to no engine power to the power train to move the vehicle."

Component: POWER TRAIN

"The 10r80 transmission of this vehicle failed resulting in erratic shifting, slowing and stopping of the vehicle in traffic, having to pull over in the middle of traffic. Rapid acceleration and deceleration resulting in jolting the people in the vehicle and abrupt speed changes. This has been confirmed by a private mechanic and a rebuilt transmission purchased from local Ford dealership. The broken transmission will be returned to Ford as the core is required to be returned for deposit refund. There were no warning lights or indications of failure other than shifting issues."

Component: POWER TRAIN

"Most mornings when I shift the vehicle from Park to Drive the transmission slams into gear and it feels like the vehicle just hit a wall. Also when shifting from 4th through 8th gear the transmission shudders through the shift sequence and sometimes it completely cuts out, total loss of power and have to coast to a stop on the side of the highway. This happens all the time."

Component: POWER TRAIN

"The cdf drum in the 10R80 transmission in 2021 Ford Expedition has failed causing inability to accelerate or decrease speech reliably. For safety during interstate driving, there is a indisputable need for quick and reliable increases and decreases in speed. Being able to clear an intersection quickly is important not only for the driver's safety but the safety of others in an intersection. Dealership has confirmed the problem. Ford released a TSB that has been around since 2023 regarding how this part fails and needs to be repaired. There were no warning lights or messages about the problem. The vehicle was purchased used at only 60,000 miles and dealership made no indication that transmissions had been an issue and could be a safety issue going forward."

Component: POWER TRAIN

"Faulty CDF Clutch Drum. The vehicle failed to shift properly while driving in mountains which could have lead to a runaway. Problem has been identified by my dealer and is a known issue with 2017-2023 Ford Expedtions. Vehicle inspected my FoMoCo mechanic and found issue with drum. No warnings or prompts before issue occurred."

Component: POWER TRAIN

"During highway operation, vehicle transmission makes very loud and angry sound and then loses ability to move , almost caused us to get hit at an intersection. Vehicle often jumps violently when shifting to reverse, and often loses propulsion when going uphill and shifting. No issues have been identified by mechanics but I have found several forums on line with drivers reporting similar occurrences. This is very dangerous and if not addressed will result in loss of life. We purchased this vehicle certified by the dealer with 92000 miles on it and it began doing this less than a week after purchase. We took it in for recall work and reported it and they said nothing was wrong with it. Manufacturer failure to rectify this very common problem is going to cause may citizens to be injured or killed."

Component: POWER TRAIN

"Have had jerky shifts and hard down shifts while driving 2021 Ford Expedition. Told dealership and was told it was normal. Then went in for oil change told the dealership about lose of power while shifting and hard shifts they advised to have transmission fluid changed. Not even 3 weeks later while pulling out onto a busy road my vehicles engine revved very high but the transmission never engaged past 2nd gear. I was almost hit by a car coming at me on the 2 lane road. After letting off the gas and then reapplying gas the transmission engaged. I drove to the dealership. Today they informed me that the transmission has multiple failures at the shift point between 1-2 and 7-8 along with hard down shifts between 4 and 3 gears. Was informed that the transmission would need to be replaced. I never got any error or warning codes that anything was wrong. I told the dealership that I felt unsafe driving the vehicle due to the transmission. The first instance happened less than a month ago. My vehicle is at the shop now waiting to have a replacement at my expense when Ford knew what the transmission is like."

Component: POWER TRAIN

"While attempting to pass a slower moving vehicle and changing from the right lane to left, I attempted to accelerate past the vehicle when the check manual light appeared on the vehicle display dashboard and I lost all power. I had no acceleration and no power from the gas pedal, after gliding past the slower vehicle and completely taking my foot off the gas pedal, the truck reset itself and power came back to the vehicle and was able to accelerate again, as if nothing happened."