2018 FORD ESCAPE Safety Overview

Component: ENGINE

"A warning light illuminated, so the vehicle was taken to the dealership for inspection. The vehicle has a history of receiving routine maintenance and repairs at this dealership. The 2.0L EcoBoost engine is known to experience coolant intrusion associated with its open-deck engine-block design, which includes narrow, slotted cooling channels—or grooves—between the cylinder bores. After inspecting the vehicle, the dealership determined that the engine block should be replaced. The estimated out-of-pocket repair cost exceeds the vehicle’s current market value."

Component: FUEL SYSTEM, GASOLINE

"The contact owns a 2018 Ford Escape. The contact stated that while driving at an undisclosed speed, the check engine warning light was illuminated. A certified mechanic was contacted and diagnosed the vehicle with evaporative emission system purge flow performance failure. Additionally, the canister purge valve needed to be replaced. The contact stated that on December 24 of 2025, the vehicle was repaired by the dealer due to a failure associated with the issue, and the evaporative canister purge control valve was replaced. The dealer was contacted; however, the vehicle was not diagnosed or repaired because the warranty had expired. The manufacturer was not aware of the failure. The failure mileage was approximately 81,131."

Component: ENGINE

"2018 Ford Escape vehicles equipped with a 2.0L EcoBoost engine may exhibit a low coolant level, white exhaust smoke and/or a runs rough condition with or without an illuminated malfunction indicator lamp (MIL). Diagnostic trouble codes (DTCs) may include P0300, P0301-P0304, P0316, P0217, P1285 and/or P1299 stored in powertrain control module (PCM). This may be due to coolant intrusion into the cylinder. To correct the condition, follow the Service Procedure to replace the long block engine assembly. THis is a known issue with a Techinal service bulletin issued on 6/9/2022. My car has only 87,000 miles on it and will need a new motor because coolant is leaking into the piston and causing a missfire."

Component: POWER TRAIN,STRUCTURE

"Transmission spudder when accelerates only at 75K miles"

Component: ENGINE

"Check engine light came on 3 weeks ago. Misfire codes on start up and cylinder 3. Mechanic replaced spark plugs, cleaned injectors. One week after repairs, check engine light came back on. Took vehicle back to the shop and after more tests, my engine showed it had suffered coolant intrusion and I was told a total replacement of the engine was needed."

Component: ENGINE

"My 2018 Ford Escape SEL has experienced coolant intrusion into the engine cylinders, a known issue affecting this model year. The vehicle began misfiring and consuming coolant without external leaks."

Component: ENGINE AND ENGINE COOLING

"The contact owns a 2018 Ford Escape. The contact stated that the engine overheated while driving, causing the contact to be four minutes late for work. There was white smoke coming from the exhaust while starting the vehicle. There was an abnormal odor coming from the vehicle. The check engine warning light was illuminated. The contact was concerned about having to purchase another vehicle. The vehicle was taken to the local dealer, where it was diagnosed and determined that there was coolant intrusion in the engine block. The contact stated that the purge valve assembly was replaced, but the failure recurred. The manufacturer was not notified of the failure. The failure mileage was approximately 38,000."

Component: ENGINE

"Vehicle developed a pattern of misfires (cylinders 1, 2, and random/multiple) beginning within the last month. On 8/7/2026, a dealer inspection confirmed coolant intrusion into cylinders 1 and 2 via overnight pressure test, with block deformation. This is the identical defect addressed by Ford Customer Satisfaction Program 21N12. Prerequisite service 19B37 (PCM reprogram) was completed 2/8/2020. Misfires and coolant intrusion of this type present a risk of sudden power loss or stalling while driving."

Component: POWER TRAIN,ENGINE

"The vehicle suffered a catastrophic engine failure due to an inherent manufacturing defect involving internal engine coolant intrusion into the cylinders. Prior to the failure, the check engine light illuminated on the dashboard, accompanied by engine misfires and rough idling. A certified service technician inspected the vehicle and confirmed that coolant is actively leaking into the engine cylinders, causing complete engine failure and rendering the vehicle entirely un-drivable. The failed engine components remain intact and are fully available for inspection upon request. This defect poses a severe safety hazard. Coolant leaking into the engine cylinders can cause sudden engine stalling, complete loss of motive power while driving at highway speeds, and potential engine fires, creating a high risk of a collision. Crucially, an authorized Ford dealership previously attempted to mitigate this exact coolant defect under warranty in 2020 by applying Customer Satisfaction Program (CSP) 19B37. This software-based patch failed to fix the underlying physical hardware defect, ultimately leading to this total engine failure. Ford has since issued CSP 21N12 for this exact issue, but the vehicle is now left broken down and unsafe to operate."

Component: ENGINE

"2018 Ford Escape equipped with EcoBoost engine suffering catastrophic engine failure due to the manufacturing defect known as open-deck coolant intrusion into the engine cylinders (per Ford TSB 22-2322). The vehicle has only 25,233 miles. This defect causes loss of power while operating the vehicle, creating an immediate traffic hazard and risk of a collision. The manufacturing flaw allows coolant to breach the cylinders, creating a stalling safety risk. Engine light is on. Ford dealer assessed and a new engine is recommended."

Component: ENGINE AND ENGINE COOLING

"The contact owns a 2018 Ford Escape. The contact stated that the vehicle failed to start immediately but started after several attempts. The vehicle was driven to an independent mechanic, where diagnostic tests were performed, but no failure was found. While driving 10–15 minutes later at approximately 30–35 MPH, the check engine warning light illuminated. The vehicle was returned to the independent mechanic, where a it was diagnosed that the canister purge valve had failed. The canister purge valve was replaced; however, the failure persisted. The vehicle was taken to the dealer, where the under-hood canister purge valve and the EVAP canister were replaced, but the failure persisted. The vehicle was not repaired. The dealer was contacted and informed that the failure was unknown. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 120,618."

Component: ENGINE

"Coolent intrusion into engine"

Component: POWER TRAIN

"Coolant is leaking into the head causing engine failure. This car has fewer than 60,00 miles. From what I have read this is a common problem and is due to a manufacturer’s design flaw. Ford refused to help me in any way when I contacted them. When I took the vehicle to the dealership they informed me that the engine would need to be replaced. The bill would be $13,000."

Component: ENGINE

"The vehicle has a 1.5L Ecoboost system which has a design flaw allowing coolant to leak into the engine. I was driving and the temperature went eradically high for no known reason and then instantly dropped. It began repeating this over and over. My mechanic told me it was a cracked head gasket and the coolant was below minimum levels because it was leaking into the engine. He told me it is a known mechanical design flaw with 2012-2019 Ford Escapes. Some were recalled some were not. Ford dealerships told me it is a known problem also. Ford will not stand behind their product and since my vehicle was not randomly picked for a recall, even though it is a known design flaw, they offer no assistance. I went online and read so very many others who have had this happen and that the reason all were not recalled was that there weren't enough complaints. So I wanted to speak out for those who didn't know how to as well as myself. I feel Ford should be held accountable for their actions. I thank God I was not stranded on a highway somewhere due to this issue or worse yet in an accicent."

Component: ENGINE

"Engine has been replaced three times already. Now, the engine has a constant cylinder 2 misfire with coolant level significantly decreasing. Car is shuddering real bad now. This is not the first time it happened. Before the third engine replacement, the car was moving on its own even with foot on the brakes. Very dangerous vehicle and unsafe."

Component: ENGINE

"Cracked engine block due to coolant intrusion, which seems to be a known problem as engine blocks were redesigned for 2019 models. Could lead to overheating, engine damage, and even fires from my understanding. In Ford dealer service center at the moment, they confirmed diagnosis. White smoke from exhaust, rough idle and sensor lights also."

Component: ENGINE

"Engine coolant in the oil. The engine needs to be replaced. The cost is greater than the value of the car.. it is a known defect that Ford knows about, but will not do anything to repair or replace the engine problem…."

Component: POWER TRAIN,UNKNOWN OR OTHER,ENGINE

"Check engine light would come on vehicle was not running well, seemed to stall. When I turned off the car I could hear liquid moving around from inside the vehicle. I am a Mom so I am driving with my 2 small children constantly and worried about their safety. The problem was confirmed by the dealership as well as an independent service center."

Component: ENGINE AND ENGINE COOLING

"The contact owns a 2018 Ford Escape. The contact stated that while driving at an undisclosed speed, a message was displayed to exit the vehicle immediately. The contact pulled over and called someone to add coolant to the vehicle, but the failure persisted. The contact was constantly adding coolant to the vehicle. The vehicle was taken to the dealer, who determined that coolant was leaking into the engine and that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 84,000."

Component: ENGINE

"I purchased my vehicle [XXX] from Suburban Chevrolet Cadillac in Ann Arbor, MI. Less than two weeks after purchasing the vehicle, my vehicle information screen informed me that the engine was overheating. My mechanic was able to replicate the issue and informed me I was the victim of a common issue with the 1.5L Ford EcoBoost Ford Escape engine that caused a coolant intrusion. I learned that Ford extended the factory warranty on the vehicle because of this issue, so they are clearly aware of it, but my vehicle was not under warranty when I purchased it used. The dealership told me they were unable to help me because I did not buy an extended warranty from them. Continuing to drive without repairing this issue could have resulted in severe engine damage, stalling, or complete mechanical failure, potentially endangering lives if it occurred while on the road. Because Ford has not issued a recall for this issue, I had to pay I had to pay $5,765.39 to replace the engine short block, inclusive of parts and labor, on top of what I paid for the car. The work was completed 11/23/2023. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)"