2022 FORD BRONCO Safety Overview

Component: FUEL SYSTEM, GASOLINE

"The contact owns a 2022 Ford Bronco. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was contacted and confirmed the part to do the recall repair was not available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure."

Component: ELECTRICAL SYSTEM

"Safety Defect – Inadequate Warning and Insufficient Time to Respond to Alternator/Charging System Failure I am submitting this safety complaint regarding a dangerous condition in my 2022 Ford Bronco involving the charging system and alternator protection behavior. While driving, a warning related to the charging system/battery appeared. The message lacked sufficient clarity and urgency. The time from the warning until the 12-volt battery was fully depleted was extremely short—too brief to safely identify a location and pull completely out of traffic. Once the battery died: • The vehicle could not be placed in neutral, preventing it from being moved out of the travel lane. • There was insufficient power to operate the hazard lights. This occurred on a busy highway, leaving the vehicle disabled in traffic and creating a significant safety risk. I was fortunate it happened in daylight. Had it occurred at night without functioning hazard lights, the likelihood of a catastrophic accident would have been high. This aligns with known alternator/charging system issues on 2021-2022 Broncos addressed in Ford Technical Service Bulletin TSB 23-2238 (superseding TSB 22-2392). The combination of an unclear warning, inadequate response time, loss of neutral capability, and loss of hazard lights presents an unreasonable safety risk. I request that Ford investigate this condition, provide a permanent remedy, and improve the warning strategy so drivers receive clear, timely notice with enough opportunity to reach a safe location."

Component: FUEL/PROPULSION SYSTEM

"The structural fuel line located on top of the fuel tank ruptured, causing highly pressurized fuel to actively spray directly toward the hot exhaust piping on my 2022 Ford Bronco (44,657 miles). This failure created an immediate, catastrophic, and potentially fatal fire risk to myself and others. There were no warning lamps, error messages, or prior symptoms leading up to this failure; the severe leak was only discovered after a routine, short-distance trip to and from a local grocery store. The vehicle and the failed component are currently available for inspection upon request. To date, the vehicle has only been inspected by myself and a local Ford dealership. The dealership visually confirmed the leak but improperly misdiagnosed the structural line failure as "rodent damage" without providing any supporting physical evidence. However, multiple online owner forums suggest this specific fuel line failure is a known, systemic manufacturing concern. I escalated this issue to Ford Customer Service (Case #CXH-08762672-F7N2Y7), but Ford denied the warranty claim based solely on the dealership's misdiagnosis. My documented physical evidence clearly shows a component manufacturing rupture, not outside damage."

Component: ENGINE

"The vehicle experienced a sudden, severe mechanical engine condition resulting in a violent rough idle, loss of motive power, and a flashing Check Engine light with hard misfire codes on Cylinders 4, 5, and 6 (the entire driver-side engine bank). Additionally, the vehicle has been losing engine coolant internally with no external leaks or puddles on the ground, indicating fluid is entering the combustion chambers. These symptoms exactly mirror the mechanical pattern documented in Ford Safety Recall 24S55 (NHTSA Campaign Number 24V635) involving brittle engine intake valves fracturing. This vehicle has an August 2022 manufacture date and sits just outside the manufacturer's current restricted recall window, indicating that the defective component batch extends significantly past the reported dates. Component Availability: The engine is intact and available for federal inspection. Safety Risk: The sudden loss of engine power, hard stalling, and severe misfires while operating the vehicle creates an immediate risk of being rear-ended by traffic or stranded on a high-speed roadway without motive power. Dealer Confirmation/Inspection: These symptoms occurred recently at roughly 58,300 miles. The vehicle is currently being towed to an authorized dealership for diagnostic confirmation, relative compression testing, and cooling system pressure testing to officially verify the root cause. It has not been inspected by police or insurance representatives. Warning Symptoms: Prior to the sudden rough idle, the vehicle exhibited a low coolant level in the reservoir. There were no dashboard warning lamps or performance symptoms prior to the sudden flashing Check Engine light and immediate hard misfires."

Component: FUEL/PROPULSION SYSTEM

"It has been a year since this recall with the fuel pump and I do t feel safe driving my Bronco everytime I start the engine."

Component: ELECTRICAL SYSTEM,ENGINE

"The contact owns a 2022 Ford Bronco. The contact received notification of NHTSA Campaign Number: 26V468000 (Engine, Electrical System); however, the part to do the recall repair was not yet available. The contact stated that while his wife was driving 70 MPH uphill, the vehicle lost drive power. Several unknown warning lights were illuminated. The driver was able to pull over to the side of the road. The vehicle was towed to the dealer, where it was diagnosed and determined that the main wiring harness had dislodged, sat across the exhaust, and was burned. The dealer determined that the main wiring harness needed to be replaced, which required the temporary removal of several components. The contact was provided a repair estimate and was advised that the failure was not covered under the recall and that the vehicle was out of warranty. The vehicle was not repaired. The contact obtained a rental vehicle out-of-pocket. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure and informed the contact that partial assistance might be provided. The failure mileage was approximately 60,908."

Component: FUEL/PROPULSION SYSTEM

"Nothing has happened yet, but I dont want to wreck or die waiting for them to create a fix. It has been a year since they issued the recall & they have built year after year of new ones, so either they are continuing to build Broncos with crappy fuel pumps,nor they have better ones that they aren't giving to us that have had the Bronco for years already."

Component: FUEL/PROPULSION SYSTEM

"MY FORD BRONCO STALLED OUT ON THE HIGHWAY GOING 70 MILES PER HOUR CAUSING ME TO HAVE TO PULL OVER TO THE SHOULDER AND RESTART THE VEHICLE! IT FEELS LIKE THE ENGINE IS MISFIRING AND NOT GETTING ENOUGH FUEL WHILE GIVING THE CAR GAS. FORD HAS NO REMEDY AVAILABLE TO FIX THE FUEL PUMP ISSUE, ACCORDING TO FORD. THIS VEHICLE HAS BECOME A TICKING BOMB WITH RECALL AFTER RECALL. MANY OF THE RECALLS ARE DANGEROUS AND THE VEHICLE IS AT REAL RISK OF A MAJOR MALFUNCTION OR FIRE AND ACCIDENT! I WANT REIMBURSEMENT FROM FORD MOTOR COMPANY FOR THE CONTINUOUS PROBLEMS I HAVE HAD ON THE VEHICLE. 23 RECALLS AND NUMEROUS OTHER ISSUES THAT I HAD TO HAVE FIXED OVER THE 4 YEARS SINCE I OWNED IT. TOTALLY RIDICULOUS AND QUITE FRANKLY UNBELIEVABLE COMING FROM A LARGE COMPANY LIKE FORD. I WANT REIMBURSEMENT FROM FORD OR FORD CAN BUY THIS PIECE OF JUNK VEHICLE BACK. TOO DANGEROUS TO DRIVE THIS BRONCO AT THIS POINT . I HAVE HAD ENOUGH OF FORD SAYING A FIX IS NOT AVAILABLE!"

Component: FUEL/PROPULSION SYSTEM

"Ford has not come up with a solution in over a year for a faulty fuel pump. Jul 08,2025 Manufacturer Recall Number25S75 NHTSA Recall Number25V455 Recall Status: Recall Incomplete, remedy not yet available. I have not had mine fail or cause an incident yet, but it says to file a complaint if the manufacturer fails to provide a solution in a timely manner."

Component: FUEL/PROPULSION SYSTEM

"On 7/19/26, I was driving my 2022 Ford Bronco Wildtrak and attempting to turn left across oncoming traffic. When I pressed the accelerator to complete the turn, the vehicle hesitated and failed to accelerate as expected. An approaching vehicle had to decelerate abruptly and honk to avoid a collision. My Bronco is subject to NHTSA Recall 25V-455/Ford Campaign 25S75 concerning loss of fuel pressure and fuel flow caused by low-pressure fuel-pump failure. I am concerned that the hesitation was related to the recalled fuel-pump condition. There were no injuries or collision, but the loss of expected acceleration created an immediate safety risk. The recall remedy is not currently available. I am requesting that NHTSA document and evaluate this incident."

Component: POWER TRAIN,ENGINE

"2022 Ford Bronco 2.7L EcoBoost VIN [XXX] has experienced recurring engine oil pressure failure causing vehicle to enter limp mode limiting speed to 25mph creating an unsafe driving condition. Diagnostic trouble codes P0524 Engine Oil Pressure Too Low and P06DD Engine Oil Pressure Control Stuck Off confirmed. Two failed warranty repair attempts at Lenoir City Ford Lenoir City TN on XXX and XXX. Dealership provided loaner vehicle both times acknowledging vehicle was unsafe to drive. Ford corporate case number XXC is open. Third repair attempt scheduled XXX.” INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)"

Component: POWER TRAIN,ENGINE

"2022 Ford Bronco 2.7L EcoBoost VIN [XXX] has experienced recurring engine oil pressure failure causing vehicle to enter limp mode limiting speed to 25mph creating an unsafe driving condition. Diagnostic trouble codes P0524 Engine Oil Pressure Too Low and P06DD Engine Oil Pressure Control Stuck Off confirmed. Two failed warranty repair attempts at Lenoir City Ford Lenoir City TN on XXX and XXX. Dealership provided loaner vehicle both times acknowledging vehicle was unsafe to drive. Ford corporate case number XXC is open. Third repair attempt scheduled XXX.” INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)"

Component: FUEL SYSTEM, GASOLINE

"The contact owns a 2022 Ford Bronco. The contact received notification of NHTSA Campaign Number: 25V455000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure."

Component: FUEL/PROPULSION SYSTEM

"35 miles out of [XXX] on Monday, XXX our Bronco loss fuel flow in the fast lane of [XXX] and stalled while going 70mph we were surrounded by trucks also going 70mph, unexpectedly mid morning. No warning . Almost got rear ended and had to safely drift over to reach the side of the road. Very terrifying with cars going very fast behind us. We attempted to restart the Bronco and it started a few times and sputtered out. I immediately called the closest Ford dealership Gaudin and they dispatched a tow truck. The temperature was very hot and we waited for 1.5 hrs in the desert sun. The dealer provided a rental but I was not allowed to leave NV nor go more than 50 miles, they confirmed that it was a bad fuel pump. I did not receive the car back until Friday 6/19/26. This incident occurred on my first day of VC planned in [XXX]. My whole vacation was ruined, unexpected expenses, and the stress of having to drive with a defective part when it’s fixed is a problem. We have to drive back to LA and I can’t miss work. We took the vehicle to Gaupin in LA to have it serviced before this trip even an oil change on 6/11/26. They assured us that all was well, only 2 recalls showed up- rear camera and a seat adjustment bolt . Why didn’t the dealer tell us about the fuel pump and the dangers. The vin number has a listed “1 un-repaired recall - fuel pump dated 7/2025. Manufacturer #XXX, NHTSA# 25V455. No notice has come through the mail and then it states Recall incomplete in red. If it was known that the fuel pump could fail, how are owners allowed to drive around without a complete recall, and without a fix. The dealer said they are going to announce on Jun 29. Well in our case that’s a little too late. Am I supposed to drive with a defective fuel system??? They replaced the fuel pump with another new pump that will have the same issue, not a fix. On June 19 later that evening after fueling it up, a service engine light came on with exhaust system issues. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)"

Component: FUEL SYSTEM, GASOLINE

"The contact owns a 2022 Ford Bronco. The contact received notification of NHTSA Campaign Number: 25V455000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure."

Component: FUEL/PROPULSION SYSTEM

"35 miles out of [XXX] on Monday, XXX our Bronco loss fuel flow in the fast lane of [XXX] and stalled while going 70mph we were surrounded by trucks also going 70mph, unexpectedly mid morning. No warning . Almost got rear ended and had to safely drift over to reach the side of the road. Very terrifying with cars going very fast behind us. We attempted to restart the Bronco and it started a few times and sputtered out. I immediately called the closest Ford dealership Gaudin and they dispatched a tow truck. The temperature was very hot and we waited for 1.5 hrs in the desert sun. The dealer provided a rental but I was not allowed to leave NV nor go more than 50 miles, they confirmed that it was a bad fuel pump. I did not receive the car back until Friday 6/19/26. This incident occurred on my first day of VC planned in [XXX]. My whole vacation was ruined, unexpected expenses, and the stress of having to drive with a defective part when it’s fixed is a problem. We have to drive back to LA and I can’t miss work. We took the vehicle to Gaupin in LA to have it serviced before this trip even an oil change on 6/11/26. They assured us that all was well, only 2 recalls showed up- rear camera and a seat adjustment bolt . Why didn’t the dealer tell us about the fuel pump and the dangers. The vin number has a listed “1 un-repaired recall - fuel pump dated 7/2025. Manufacturer #XXX, NHTSA# 25V455. No notice has come through the mail and then it states Recall incomplete in red. If it was known that the fuel pump could fail, how are owners allowed to drive around without a complete recall, and without a fix. The dealer said they are going to announce on Jun 29. Well in our case that’s a little too late. Am I supposed to drive with a defective fuel system??? They replaced the fuel pump with another new pump that will have the same issue, not a fix. On June 19 later that evening after fueling it up, a service engine light came on with exhaust system issues. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)"

Component: ENGINE

"While driving on an interstate it was determined that the engine walls over compressed and blew out the sides of the motor of my 2022 Ford Bronco. The Bronco has 67,000 miles on it which shows a clear manufacturer defect. It is available to be inspected as well to confirm. My wife’s and unborn child’s safety was put at risk by losing acceleration and losing control of the vehicle briefly as it began to shake from the engine misfiring. This easily could have caused a serious wreck had more traffic been present at the time. The dealership has not been able to confirm this on other cars. The engine has been inspected by a Ford Dealership. There were no warning lamps or messages prior to the failure and only appeared shortly after the engine over-compressed and began to shake."

Component: STRUCTURE

"The Molded-In-Color (MIC) hard top shows signs of delamination and cracking on the exterior skin of the roof panel. Models from the same production year were called under NHTSA Recall No.: 26V299. My vehicle was not included on this recall. I have attempted to have Ford inspect the issue and have refused since it is out of warranty. I am concerned that the delaminating sections will detach while driving."

Component: POWER TRAIN,ENGINE

"While operating the vehicle under load, the vehicle suffered a sudden and severe loss of engine performance, followed immediately by loud metallic banging from the engine bay. The vehicle lost all power and was immediately disabled (LIMP MODE), presenting an imminent highway safety hazard.The Physical Damage: Subsequent mechanical teardown revealed deep vertical cylinder wall scoring, heavy raw fuel residue in the engine oil pan, and a blown head gasket. Relationship to Active Safety Defect: This catastrophic block failure perfectly mirrors the progressive failure profile of NHTSA Campaign 25V455 / Ford Safety Recall 25S75 (Low-Pressure Fuel Pump Failure). Internal component degradation in the fuel tank delivery module dropped fuel pressure to the engine. Under turbo boost, this starvation induced an extreme, instantaneous lean-out condition. The resulting low-speed pre-ignition (LSPI) exploded and shattered the internal piston rings (the metallic banging), leading to mechanical wall gouging, unburnt fuel wash into the lower crankcase, and a secondary blown head gasket. Request for Action: Ford's current VIN parameters for Recall 25S75 have not yet captured my specific vehicle despite it matching the exact production window, component setup, and catastrophic failure sequence. I am requesting that the NHTSA log this case as clear evidence of consequential engine destruction originating from the 25V455 pump defect, and evaluate whether Ford's recall scope must be expanded to protect other consumers from highway engine failures."

Component: POWER TRAIN,ENGINE

"The Incident: While operating the vehicle under high load, the driver received an explicit "Service Engine Soon" powertrain malfunction alert stating: "The powertrain control module lost communication with the vehicle active grill shutter module for a period of time." Immediately following this warning, the engine experienced a severe loss of power, followed by loud metallic banging from the engine bay. The vehicle stalled completely and lost all motive power, creating an imminent highway safety hazard.The Physical Damage: Subsequent mechanical teardown by the dealership revealed terminal block destruction, including deep vertical cylinder wall scoring, heavy unburnt liquid gasoline residue in the engine oil pan, and a blown head gasket.Relationship to Active Safety Defect: This catastrophic engine failure mirrors the progressive failure profile of NHTSA Campaign 25V455 / Ford Safety Recall 25S75 (Low-Pressure Fuel Pump Failure). In this EcoBoost architecture, the Active Grill Shutter (AGS) module shares critical voltage paths, grounding blocks, and wiring looms with the engine management and fuel delivery systems. The sudden network communication loss is diagnostic proof of a severe voltage drop or electrical short caused by the high-friction fuel pump degradation detailed in Recall 25S75. This circuit failure instantly starved the engine of fuel under turbo boost, inducing an extreme lean-out condition. The resulting pre-ignition forces violently shattered the internal piston rings (the loud banging), which then gouged the cylinder walls, wiped out compression, fouled the crankcase with fuel residue, and blew the head gasket.Request for Action: Ford's current VIN parameters for Recall 25S75 have not yet captured my specific vehicle despite it matching the exact production window, component setup, and catastrophic failure sequence. I am requesting that the NHTSA log this case as definitive evidence of consequential engine destruction originating from the 25V455 fue"

Component: UNKNOWN OR OTHER

"Complete clutch failure at 39,000 miles. Unable to shift or safely restart vehicle once stopped. Clutch Hydraulic line came completely apart. Ford part number MB3Z-7A512-A. Failure verified by independent SAE certified mechanic. Note: Clutch and Brakes feed from the same reservoir, so loss of clutch hydraulic fluid also impacts entire braking system."

Component: SERVICE BRAKES

"I drive a Standard ‘22 Bronco. Only E-brake works for parking brake when in parking lots and such. My Bronco rolls into oncoming traffic and pedestrians when the e-brake releases. I am former Homeland Security and this unacceptable, as this if my 10th issue with the Ford Bronco! Safety First!"

Component: STRUCTURE

"The hard top is cracking and letting water into the cargo area. It seems to be right outside the parameters for recall number 26S32. Talk to dealer over a month ago and have not heard back yet."

Component: UNKNOWN OR OTHER

"Latch for the swing gate is locked in the closed position so the swing gate will not latch closed. It swings open while driving"

Component: SERVICE BRAKES

"There has been an SSM release by Ford (SSM 51415) acknowledging that 2021-2022 Bronco vehicles flat towed in neutral may experience inconsistent or unintended ABS (anti-lock brake) module activation while being towed. The ABS module exits sleep mode unexpectedly due to road vibration input during towing, which can cause brake drag or lockup while the vehicle is being flat towed behind a motorhome. This is a safety concern as unexpected braking of the towed vehicle can affect the towing vehicle's stability and control at highway speeds. The vehicle is being operated exactly as documented in the Ford owner's manual, which explicitly supports neutral flat towing. Ford has developed a software update to address this defect but is declining to cover it under warranty or goodwill, instead classifying it as non-covered maintenance. The issue has been confirmed by an authorized Ford dealership who identified SSM 51415 as applicable. A community workaround requiring removal of fuses 28 and 29 to disable the ABS pump has emerged among owners, indicating this is a widespread known issue affecting safety during a manufacturer-approved towing method. Ford should issue a TSB or recall and cover the software correction at no cost to owners."

Component: FUEL/PROPULSION SYSTEM

"There has been a Safety recall in the fuel pump for almost a year, with documented known issues existing well before the release and Ford has still yet to make a remedy available."

Component: STRUCTURE

"Cracks in left rear of roof theirs a recall ones that painted but not on the matt finish one. My 2022 Ford Bronco 2 door is showing the same problems as the paint ones. And Ford Dealership said they at least a dozen or more around his dealership with the same issue. And online I have been told of 100s. Have the same thing happening to their Broncos the years 2021 to 2024 even ones sit on lots for with the same problems."

Component: FUEL/PROPULSION SYSTEM

"My 2022 Ford Bronco experienced recall 25S75 where fuel pump failed while driving on the freeway outside LA near San Bernardino. Recall was communicated in July of 2025 and no fix available. How long has Ford been building cars? There were no warnings or symptoms prior to failure. This was extremely dangerous for car to stall in the middle of the freeway, not to mention it was 98 degrees outside. I was able to tow my Bronco to a Ford dealership where they confirmed and fixed the recall fuel pump issue."

Component: SERVICE BRAKES

"On May 7, 2026 while driving approximately 18 mph, my Ford Bronco 2022 Outerbanks experienced a sudden loss of normal braking assist. The brake pedal became stuck in the upright position requiring excessive force to stop the vehicle. When the brake pedal went down the truck rolled to the curb and I put it in park. There was a warning sign on the dash that flashed and went away. I could not see what it was. Luckily there were no bystanders or other cars on the road at the time. I was near an elementary school at the time. This would have caused a crash or worse if there were pedestrians. I turned the truck off and called the tow. At the dealership they diagnosed and confirmed an electronic brake booster (EBB) failure. This EBB failure mirrors a recent recall from Ford affecting 2025 Broncos. The dealership has refused warranty because I am 6 months outside the warranty period even though I only have 29,960 miles. This is not normal wear and tear. The 2025 recall # is 25V488. This EBB recall may also affect previous years such as mine and should be investigated."

Component: FUEL SYSTEM, GASOLINE,BACK OVER PREVENTION

"The contact owns a 2022 Ford Bronco. The contact stated that while attempting to reverse, the rearview camera became inoperable. The contact stated that the rearview camera image failed to function and the image would appear as blank. The contact received notification of NHTSA Campaign Numbers: 26V124000(Back Over Prevention) and 25V455000 (Fuel System, Gasoline), however, the part to do the recall repair was not yet available. The dealer was contacted. The vehicle was not diagnosed or repaired. The dealer confirmed that the remedy parts were not yet available. The manufacturer was made aware of the failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The approximate failure mileage was 35,000."

Component: ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL,FUEL/PROPULSION SYSTEM

"Vehicle has Surged and stalled randomly, the Crash alert warning appears on screen and starts to stop the vehicle with nothing in front of it, I have asked my Ford Dealer to remedy the recalls as I have paid over $50,000 for the vehicle and they tell me sorry there are no fixes, I tried to trade it in, and they said they cannot because they have a no sale enforcement on the Bronco and they said if they took it in trade they could not sell it."

Component: STEERING,FORWARD COLLISION AVOIDANCE

"Truck began scrolling warnings that pre-collision braking, hill start assist, forward collision, adaptive cruise control, and more were all not working. Alerts came out of no where while driving on highway and continued every 30 min to hour of drive time. Cruise control was disabled with this failure. Diagnosed with faulty steering-rack. This has been recalled on other 2022 Ford Broncos, but for some reason our was not included in this recall. This lot was clearly impacted as well. The truck is used for daily driving, does not go off-roading and was not involved in any collision or incident that triggered this, simply driving down the highway. Please let Ford know to expand the recall, our car is not safe to drive and is not inoperable unless we pay for the repair or the recall is expanded. Thank you for your assistance!"

Component: STEERING

"The steering is unsafe, my neighbor works at a ford dealership and said it’s the rack, which I also read online that it’s become a common problem, the steering has become very stiff. To the point where I have had to slam on the breaks at curves in the road just to be able to turn into the bend, which has almost caused two incidents."

Component: SERVICE BRAKES

"Anti lock beake system warning light. Very hard to press brake pedal. Brought immediately to dealership. Was told Brake vacuum hose Part # MB3Z 2420 L. Part is not covered by any warranty standard or extended. Also told this is a known issue SSM 50472. Safety of driver, passengers and public placed in danger."

Component: SERVICE BRAKES

"Vehicle brake pedal is very hard to press, unable to push in until the car engine is running. When driving the brake pedal seems it has more pressure and cannot push it to normal level. On the highway it came up brake safety warning when I was in 4Wheel Auto. The pedal stiffness has been checked and confirmed by AutoNation Service. They stated no Warranty or Recall Notice for this issue. The issue is commonly reported by broncos with 2.3L and is determined to be the Brake Booster Vacuum Line. Statements share similar brake pedal stiffness when engine stopped, and engaged stiffness when in 4 wheel mode or Cruise Control, causing driver to put immense pressure on pedal to have the car brake. Before I pay for the parts and long service this clear safety concern should be looked at."

Component: STEERING

"On April 3rd, 2026 my steering started to intermittently lock up on my 2022 Ford Bronco. I immediately took my vehicle to my local dealership where they were able to recreate the problem. The vehicle was also throwing the code U3000:49-8A for steering gear failure. This issue appears to be consistent with the Ford Safety Recall 23S09. There was no warning prior to the issue. There were no warning indicators once the issue began."

Component: STEERING

"I was operating the vehicle on the highway and the steering locked up. I had no indication that this was going to happen. It would not turn and almost caused an accident. I was able to break the steering do to my strength. I was able to limp truck to dealer. Upon inspection they confirmed a faulty / locked up steering shaft. This was not covered by ford. The shaft was replaced and functional now. I have made several attempts to communicate with corporate ford about this safety matter and haven’t been heard from. They have had shaft issues with their f150 trucks also. This issue is a direct result from poor manufacturing and is a real safety issue. This should never happen with a vehicle that is only a few years old with not that many miles.I have saved the part for inspection and looking for some assistance. Thanks you."

Component: FUEL SYSTEM, GASOLINE,SEATS,BACK OVER PREVENTION

"The contact owns a 2022 Ford Bronco. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power with several unknown warning lights illuminated. The vehicle was towed to the dealer, where it was diagnosed, and determined that the fuel pump had failed and needed to be replaced. The vehicle was repaired. The contact stated that after the repair, while driving at an undisclosed speed, the vehicle unexpectedly shook and sputtered. There was no warning light illuminated. The contact received notification of NHTSA Campaign Numbers: 25V455000 (Fuel System, Gasoline), 25V721000 (Seats), and 26V124000 (Back Over Prevention); however, the parts to do the recall repairs were not yet available. The dealer was contacted. The vehicle was not diagnosed or repaired. The dealer confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure, and a case was opened. The approximate failure mileage was 35,000."

Component: FUEL SYSTEM, GASOLINE,SEATS

"The contact owns a 2022 Ford Bronco. The contact received notifications of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline) and 25V721000 (Seats); however, the parts to do the recall repairs were not yet available. The dealer was contacted, and the contact was informed that parts were not yet available. The manufacturer was contacted, and the contact was informed that parts were not yet available. The contact had not experienced a failure."

Component: FUEL SYSTEM, GASOLINE,SEATS,BACK OVER PREVENTION

"The contact owns a 2022 Ford Bronco. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power with several unknown warning lights illuminated. The vehicle needed to be towed. The contact was informed that the VIN was included in NHTSA Campaign Numbers: 25V455000 (Fuel System, Gasoline), 25V721000 (Seats), and 26V124000 (Back Over Prevention); however, the parts to do the recall repairs were not yet available. The vehicle was towed to the dealer to be diagnosed, and it was determined that the low-pressure fuel pump had failed and needed to be replaced. The vehicle was not repaired, and the dealer confirmed that the parts were not yet available. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for additional assistance. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The approximate failure mileage was 40,000."

Component: STRUCTURE

"Ford has issued a recall for 2021- Jan 2022 hard tops. Mine is a June 2022 with the same issues but not listed in the recall. This has been a known issue for the life span of the Bronco."

Component: STRUCTURE

"Ford has issued a recall for 2021- Jan 2022 hard tops. Mine is a June 2022 with the same issues but not listed in the recall. This has been a known issue for the life span of the Bronco."

Component: STRUCTURE

"Noticed that my hardtop was cracking around the rear windows. This is a know issue with Ford and is being replaced under warranty. Unfortunately, my vehicle is outside of the original 3 year 36,000 mile warranty period by just over 6,000 miles that would qualify for replacement. The dealer quoted over $10,000.00 to replace the entire top since all roof panels appear to be affected. This is almost 1/4 the cost of my vehicle on the used market and is unacceptable for a know issue that would normally be replaced under warranty."

Component: BACK OVER PREVENTION

"The contact owns a 2022 Ford Bronco. The contact stated while reversing, the rear view camera displayed a blank screen. The vehicle was taken to the dealer where the contact was informed that the parts were unavailable. The vehicle was not repaired. In addition, the contact was informed that the parts were not going to be available until July 2026. The contact received a recall notification, NHTSA Campaign Number: 25V455000 (Back Over Prevention) however the parts were unavailable. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 27,800."

Component: BACK OVER PREVENTION

"The contact owns a 2022 Ford Bronco. The contact was informed of the NHTSA Campaign Number: 23V165000 (BACK OVER PREVENTION); however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact experienced the failure and became aware that the back-over prevention camera had malfunctioned, and a black screen was displayed. The failure mileage was 35,900."

Component: FUEL SYSTEM, GASOLINE

"The contact owns a 2020 Ford Bronco. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed, however, the vehicle failed to accelerate as intended. The check engine warning light illuminated and the engine seized. The contact stated that while attempting to start the vehicle, the vehicle failed to start as intended. The vehicle was towed to the residence. The mobile independent mechanic came to the residence, and the vehicle was diagnosed with a failed low pressure fuel pump. The contact was informed that the low pressure fuel pump needed to be replaced. The vehicle was not repaired. The dealer was made aware of the failure. The contact was informed that the parts were unavailable. The contact received a recall notification, NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline) however the parts were unavailable. The manufacturer was not made aware of the failure. The failure mileage was approximately 25,000."

Component: POWER TRAIN,UNKNOWN OR OTHER

"Differential carrier replacement due to metal contmination being found in differential during oil change and a transmission overhaul due to excessive wear of(clutch container, CDF bushing, forward hub and front support bushings). They also noted a sticking valve in the main control on my 2022 Ford Bronco 2.7L V6 when taken in to dealership to evaluate vehichle under warranty due to ongoing intermittent thump/clunking noise when coming to a stop and accelerating from a stop as well as when backing up from a stop and while driving as well, intermittent loud metal slapping sound at speeds over 60 mph, intermittent jerking of vehichle when cycling through gears, unexpected downshift at high speeds. After differential replacement and transmission overhaul due to excessive wear while under warranty, my vehichle continues to experience the same symptoms and problems and feel this is a safety issue."

Component: LANE DEPARTURE,BACK OVER PREVENTION

"Getting a cross traffic alert and blind spot alert fault warning every time I drive the car."

Component: ENGINE AND ENGINE COOLING,FUEL SYSTEM, GASOLINE

"The contact owns a 2022 Ford Bronco. The contact stated that while her husband was driving 65 MPH, the vehicle unintendedly decelerated and jerked abnormally. The driver pulled over to the shoulder of the road and inspected the vehicle. The driver then drove to the dealer, where the vehicle was diagnosed as having a contained fire inside the exhaust pipe. The vehicle remained at the dealer for further diagnostic tests with the assistance of the engineers. The dealer informed the contact that the manufacturer had denied the contact vehicle rental assistance. The vehicle was not yet repaired. The contact stated that with the three recalls, it was unsafe to continue driving the vehicle. The manufacturer was notified of the failure. The failure mileage was approximately 80,000."

Component: ELECTRICAL SYSTEM

"What component or system failed or malfunctioned, and is it available for inspection upon request? - Display for backup camera freezes after putting vehicle in reverse. Yes, it is available for inspection. How was your safety or the safety of others put at risk? - The display freezes when putting the vehicle in revers and the initial image on display of what was behind the vehicle stays the same while moving. If something or someone moves behind the vehicle while moving the image does not update to show that something or someone is now behind the vehicle. Previously recall 23S48 was completed related to the issue but it did not resolve the issue. Vehicle was taken back to the dealer and the dealer informed me that it is a faulty APIM and not the backup camera and is therefore not covered by the recall. This is a significant safety issue and needs remedied regardless of what component needs replaced. Has the problem been reproduced or confirmed by a dealer or independent service center? - Yes Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? - Only by the dealer (Midwest Ford in Hutchinson, KS). Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? - No"