2020 CHEVROLET SILVERADO 1500 Safety Overview

Component: VEHICLE SPEED CONTROL,FUEL/PROPULSION SYSTEM

"I received a notice via OnStar of a P129 code of a critical issue with engine or transmission system on my 2020 Silverado pickup after I pulled on to the highway. Vehicle reduced engine power warning and engine light came on. I was forced to put vehicle in neutral and restart vehicle several times. This code indicates fuel pump control module being defective. After researching, there seems to be issues with this on the the following; General Motors has issued voluntary emission recalls (such as bulletins N252516900 and N262558690) for the fuel pump power control module on select 2021–2023 Buick, Cadillac, Chevrolet, and GMC vehicles. The issue with my vehicle is the same."

Component: ENGINE

"The contact owns a 2020 Chevrolet Silverado 1500. The contact stated that while driving 65 MPH, the engine lifters failed to operate as intended. Additionally, the lifters were replaced three years prior to the failure reoccurring. The dealer was contacted and the vehicle was diagnosed with lifter failure. The manufacturer was contacted by phone and made aware of the failure. The failure mileage was approximately 120,000."

Component: ELECTRICAL SYSTEM

"What component or system failed or malfunctioned, and is it available for inspection upon request? The A/C condenser and the vehicle battery failed. The failed components are available for inspection upon request. How was your safety or the safety of others put at risk? The A/C failure causes the driver's side to blow warm air, creating severe window fogging and reducing visibility in extreme weather, while the electrical/battery failure compromises vehicle operation and safety features. Has the problem been reproduced or confirmed by a dealer or independent service center? The A/C issue matches General Motors Technical Service Bulletin PIT5767A, caused by an internally bypassing condenser due to a mispositioned block-off plate. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? The vehicle has not yet been officially inspected by a manufacturer representative, but the defect aligns with known GM manufacturing specifications under bulletin PIT5767A. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Symptoms appeared suddenly with the air conditioning losing performance (driver's side blowing significantly warmer than the passenger side) alongside concurrent battery and electrical system failures."

Component: POWER TRAIN

"The contact owns a 2020 Chevrolet Silverado. The contact stated that while driving between 20 mph and 60 mph, the vehicle shudders a lot while accelerating. The vehicle was taken to an independent mechanic where it was diagnosed with a failure in the transmission. The contact stated he contacted a dealer where they confirmed the failure but stated there are no recalls nor TSBs related to the failure, although there are recalls for different model vehicles that have the exact same transmission as the contact's vehicle. The contact referenced TSB 19-NA-121 (powertrain); however, the VIN was not included in the repair. The contact stated he could feel the shaking shuddering. The manufacturer was notified of the failure. The vehicle was not repaired."

Component: ENGINE

"I was driving down the highway doing 70mph when my check engine light started flashing. I had to pull over and turn off my truck and turn it back on in order for it to go away. I brought it to the dealership and they explained that I had a misfire on the entire driver side of the engine and I would need to replace it. I have kept up on all of my vehicle maintenance but it still requires a new engine, costing $11,000 if not covered under warranty. This is a known problem with the Chevrolet 6.2L V8 engine and is now a class action lawsuit with the company."

Component: POWER TRAIN,ELECTRICAL SYSTEM

"rear axle locks up and transmission goes into limp mode , this happens when slow speed under acceleration, this happens almost any time in traffic , at stop light , acceleration to freeway. a safety issue, shows a p0700 code and p2729 code , engine service code light goes on , T/C and skid lights. also happen at hard brakes in traffic lights or fast slow downs"

Component: SERVICE BRAKES

"While driving my 2020 Chevrolet Silverado 1500, the braking system suddenly malfunctioned without any prior warning. When I released the accelerator, the vehicle began slowing as though the brakes were being applied even though I was not pressing the brake pedal. When I attempted to brake normally, the vehicle did not stop as expected and braking ability was significantly reduced. The red BRAKE warning, ABS warning, traction/ESC warnings, and check engine light illuminated. The dashboard displayed “Brake System Failure – 43 MPH Top Speed,” “Service ESC,” and “Service Trailer Brake System.” Because of the reduced braking ability, I stopped the vehicle and had it transported by flatbed tow to a Chevrolet dealership rather than continue driving it. The Chevrolet dealer inspected the vehicle and documented diagnostic trouble codes P25A2 and C053D. The dealer stated that the Brake System Control Module requested the warning light and that updated software was available to address these codes. The dealer reprogrammed the Brake System Control Module according to a GM technical service bulletin. No mechanical brake components were replaced. I was charged $362.95 for the diagnosis/reprogramming. I am reporting this because the failure occurred suddenly while the vehicle was being driven and resulted in significantly reduced braking ability, creating a serious risk of a crash. The vehicle had approximately 74,221 miles at the time of the incident. The dealer repair invoice documenting the codes and repair is available upon request."

Component: ELECTRICAL SYSTEM,STRUCTURE,UNKNOWN OR OTHER

"Rear windows water leak. May caue electrical issues and mold in the cab"

Component: POWER TRAIN,ENGINE,FUEL/PROPULSION SYSTEM

"have notice that the car jerks hard from time to time and when try to accelerate the car does a quick/short stop then accelerates hards very jerky. Also I smell coolant and my check engine light came on.."

Component: POWER TRAIN,ENGINE

"Vehicle is hard shifting and has the following error codes. Engine P0700 Transmission Control Moduel Requested, test not passed Transmission P0747 Transmission control solenoid Valve 1 stuck on- Test failed. Warning indicator requested. Very concerned to be driving this vehicle."

Component: VEHICLE SPEED CONTROL,WHEELS,SERVICE BRAKES

"1) The vehicle experienced a rear axle/rear-wheel lock-up after the recall-related repair was performed and the same diagnostic codes associated with the initial repair reportedly returned. 2)The rear axle/rear wheels locked while the vehicle was being driven on the highway, creating a significant loss-of-control and collision hazard. A sudden drivetrain/axle lock-up at highway speed causes the vehicle to stop or behave unpredictably, potentially resulting in a severe collision 3) Yes. Huffines Chevrolet performed the initial recall-related repair and subsequently the same diagnostic codes reportedly returned after said repair 4) The vehicle has been inspected by 2 Chevrolet dealerships, including Huffines Chevrolet and El Dorado Chevrolet/Motors. The matter has also been reported to GM Customer Assistance under Case No. 110236243 5) Yes. Diagnostic codes associated with the recall-related issue were present when the vehicle was initially taken to Huffines Chevrolet on August 10, 2026. Huffines performed recall-related repairs, including replacement of the transmission module as part of the attempted repair. After the vehicle was returned, the problem recurred. On August 28, 2026, while driving on the highway, the rear axle/rear wheels locked, and the same diagnostic codes reportedly returned."

Component: ENGINE

"Motor blew up. 6.2 L87. 2020 silverado 90000 miles, this will be the 4th motor"

Component: STEERING,ELECTRICAL SYSTEM

"While driving I lost the power steering on the vehicle. I took my truck to a chevy dealership and scheduled an appointment for the following day. I research the problem and found that there was a Customer Satisfaction Program bulletin (N252515590) issued covering this specific issue for my trucks model year but it did not cover my specific VIN. I contacted Chevrolet Customer Assistance and they told me to file a complaint with NHTSA."

Component: STEERING,ELECTRICAL SYSTEM,EXTERIOR LIGHTING

"Body to frame ground cables corroded in half two different times within about 6 months. First time engine wouldn’t start had to have it towed to dealer for repair, over 30 codes were shown when this happened. Next incident some of my lights were working intermittently and my steering was rendered inoperable for 20 to 30 seconds at a time making it impossible to steer the vehicle, several codes were found when this happened, I drove the truck to a Chevrolet dealer for repair. Both repairs were deemed to be corroded ground cables. Chevrolet has a “customer appreciation program” covering 2019-2024 Silverado trucks but for some reason my VIN number doesn’t land in the program even though it has the same issues that are covered for the other silverados."

Component: POWER TRAIN

"I have notice that the car jerks hard from time to time and when try to accelerate the car does a quick/short stop then accelerates hards very jerky."

Component: SERVICE BRAKES

"Complete brake system, master cylinder, pads, rotors. Only 75000- miles. Morning start and the brakes are locked up. Had to get towed and the entire system needed to be replaced. So after several days and almost 5,000 I started driving home. After about 5 miles something fell off the front brakes and bounced along underneath but I was close to home so I continued and didn't need to apply the brakes until my driveway and then a terrible grinding sound. Called the dealer (Modern Chevrolet) Winston-Salem NC. Turns out the Einsteins who did the work forgot to tighten the bolts holding the rotor and one fell out and the other one was grinding against the wheel. So another extended stay at the dealership to correct this, a new wheel and correction to the brake components."

Component: POWER TRAIN

"My transmission was shuttering from about 10,000 miles to 67,000. I reported it multiple times to the dealership and they did nothing about it until the 67,000 mark when they finally replaced it. the new transmission started to downshift very hard as soon as I got it back from the dealer and it just got worse I took it back and they had diagnosed that it was bad. They are in the process of replacing the transmission, a second time which would be my third transmission They’ve had my truck for 36 days. Clearly, General Motors and the dealership cannot figure out how to get my transmission to work properly. It’s a danger to my family and those on the road if it fails while on the highway."

Component: POWER TRAIN,ENGINE

"The contact owns a 2020 Chevrolet Silverado 1500. The contact stated that the engine was previously rebuilt. While driving at an undisclosed speed, the vehicle jerked and lost motive power, with several unknown warning lights illuminated. The vehicle was pushed to the side of the road and towed to an independent mechanic, who determined that the engine had low compression, and that the engine and transmission needed to be replaced. The manufacturer was notified of the failure by phone. The failure mileage was approximately 140,000."

Component: POWER TRAIN,ELECTRICAL SYSTEM,ENGINE

"The contact owns a 2020 Chevrolet Silverado 1500. The contact stated that while driving, the vehicle was shuddering. The vehicle was taken to the dealer and was diagnosed with transmission failure. The contact was informed that the torque converter and transmission needed to be flushed. While driving approximately 30 MPH, the vehicle was shuddering and the transmission seized, with the check engine warning light illuminated. The failure had occurred briefly, and the failure was self-corrected, and the contact continued driving. The failure reoccurred approximately 2 - 3 times. The vehicle was returned to the dealer, and the transmission was replaced. The failure persisted, and the vehicle was returned to the dealer, and the transmission was replaced a second time. The vehicle was returned to the dealer, who was unable to diagnose or repair the vehicle. The contact drove the vehicle an additional 20,000 miles before the vehicle received additional repairs. The manufacturer was informed of the issue several times. The failure mileage was approximately 73,000."

Component: POWER TRAIN

"Transmission failure around 63000miles. Jasper rebuilt transmission having issues at 130000"